F7003-0301现货 in stock! 欢迎来电咨询~！！

F7003-0301,

F7003-0301

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

104-1541CLDN

ACL-8112PG

DF0201024-B0

DELL Studio XPS 9000

HAL-8308

CONTEC PI-32L(PC)V

1492-SBSTP IEC Term Blck Gray Start Plug

软启动器 3RW40272TB04

行程开关 3SE53120SG12

运行版软件 6AV2105-0MA14-0AA0 SIMATIC WinCC Runtime 专业版 65536 PowerTags ASIA V14

1585J-M4UBJM-1 RJ45 Ethernet Media

1756-OV32E ControlLogix 32 Point D/O Module

188-K1C160 Miniature Circuit Breaker 16 A

194E-KA16E-P11 194E Load switch

2090-CFBM7DF-CEAA60 MP-Series 60m Servo Feedback Cable

2090-UXLF-HV330 Ultra Series 30A AC Line Filter

BC646SPB365 Solution Provider Additional Seat - Euro

GC647IFCLNTSRO010 GCC iFIX iClientTS Read Only 25 PK Runtime Version

IC200ALG325 Analog output 13 bit voltage 8 channel

IC646MBP001 Machine Edition Professional Development Suite

IC647IFPRDV00900M iFIX Profsnl SCADA 900 I/O Development (M4 Part)

IC660SLA104 Red Safety Label Kit for IC660BBA104 Genius Blocks

IC697CGR772 Hot Standby Genius Dual Bus CPU, 486DX4, 2K Discrete I/O, 512K byte fi xed user memory, Floating Pt.

IC800CBL022 Encoder cable for B0.5/3000 motor. 14 meters

ControlLogix/1756 System 1756-M22 LOGIX5555 750K NV MEMORY MODULE

Industrial Computers 6182H-7KEH6B VVCE 700, KEYPAD, EXT MEM, RIO/DH, AC

Process Control 9358-PBANT03ENE RSBATCH NT FOR PROCESSLOGIX ARCHIVER 03 UNITS

Operator Interface 2711P-K15C6D2 PV PLUS 1500, KEYPAD, RIO/DH, DC PS, EXT MEM

Support 9352-WDN100R SUPT REINSTATEMENT CONTRACT FOR 9352WDN100

Support 9324-RSECSENR SUPT REINSTATEMENT CONTRACT FOR 9324RSECSEN

ControlNet Products 1786-BNC IMPROVED CONTROLNET RG6 COAXIAL CONNECTOR

RSI Software Products 9301-2SE2353ZHE RSVIEW32 WORKS 5K WITH RSLINX (CHINESE)

RSI Software Products 9352-WAB300D WINTELLIGENT LINX

RSI Software Products 9399-WTDGR RSTREND GETTING RESULTS GUIDE

Motion Control 2090-DAIO-D5003 CABLE, NON-FLEX, CN1 CONTROL, 03M

BC646MVSU01 View Standard Edition with SAFE - Upgrade from QuickDesigner

IC300TRM006 Spring-clamp style I/O plug, 6-terminal

IC800ABK001 Battery Backup Kit, Alpha SVU Series Amplifiers

MTR-3T67-G-R-B-M-0RR Servo Motor Metric 24V Brake

PCI-8513

SDK-1066

PIA-652DV-A

DCI920414

FB-CBXSB-02

PIO01

1492-LS2-B IEC Sensor Blck 5.1x68x38.5mm Sprng Clip

1494G-EF3N NEMA 1494G Enclosed Disconnect

软启动器 3RW44432BC46

ET 200SP 6ES7134-6HD00-0BA1 AI 4xU/I 2 线制 标准型，基座单元类型 A0、A1

1585D-M4DC-SH Ethernet Media

1756-A7 ControlLogix 7 Slots Chassis

1794-IH16 Flex 16 Point Digital Input Module

194E-CA00E-TN-PE 194E Load switch

2080-LC50-48QVB Micro850 48 I/O EtherNet/IP Controller

2090-CSWM1DF-18AA17 Kinetix Cable Single DSL 2090-Series

20AC3P5F0AYNANC0 PowerFlex 70 AC Drive 20A

GC646MRB075 Proficy GlobalCare Complete for Logic PC Runtime 75 I/O

HE693SRC844 PC Interface C Driver Source Code

IC610MDL175RR 115/230Vac Output Module (8 points)

IC647HSTSS150KM Historian Standard Server 150000 Points (M4 Key)

IC660BBD110 Block 115Vac Input 16 Circuits

IC695ACC400CA Conformal Coated. RX3i CPU Energy Pack. Compatible with IC695CPE305 and IC695CPE310 only. Energy Pack ships with CPE305 and CPE310.

IC756WDS000E-23 Dataviews Development Suite (All Windows Languages, Custom Editor Tool kit, Custom Datasource Toolkit, 1 yr SAFE), English, Version 2.3

CompactLogix System 1769-IQ16F 1769 16 POINT HIGH SPEED 24VDC INPUT MODULE

PLC-5/1771 System 1770-XYC LITHIUM BATTERY FOR PLC-5 PROCESSORS

Distributed I/O 1798-PFTP1 PROFIBUS FIELD TERMINATION PLUG W/ 12MM CONNECTORS

Operator Interface 2711P-K6C8D PV PLUS 600 COLOR, KEYPAD, DH+, DC PS

Support 9323-WL5300R SUPT REINSTATEMENT CONTRACT FOR 9323WL5300

Support 9358-PBBK03S SUPT RENEWAL CONTRACT FOR 9358PBBK03ENE

Support F1775-L4 FIRMWARE UPGRADE FOR 1775-L4 PLC3 PROCESSOR MODULE

RSI Software Products 9324-RLT300ENE RSLOGIX 5/500/5000 ENGLISH CD BUNDLE

RSI Software Products 9701-VWMR015ADEE RSVIEW ME STATION RT 15 DISP-WINDOWS 2000 (GERMAN)

RSI Software Products 9330-GC200U UPGRADE: IN-SUPT: RSGUARDIAN CORE 24 TO 128 NODE

Motion Control 2094-PRS4 POWER RAIL, SLIM, 230V OR 460V, 4 AXIS

A06B-6089-K250 Fuse, Alpha SVU Series Amplifier Control Power

IC200UEX209-24 Qty of 24, 28 point expansion. (16) 120VAC In, (12) Relay Out (2 at 10 amp & 10 at 2 amp), 120/240VAC Power Supply (includes Ic200CBL501)

IC752CDS049 Control Station CE IIx Controller 10.4 " Display with RT license.

MTR-3N24-G-R-0-N-SRR Servo Motor Nema23 with Seal

NI 9381

PSC-586

ADAM-4068

AOM-TPM-9655V

NORCO-730V

DMC5410 DMC3410

1492-J35-Y IEC 1-Ckt Feed-Through Blk 35mm

1492-SPM3D130 MCB Supplementary Protector 13 A

软启动器 3RW40381TB05

SIMATIC HMI 系列面板 6AV2124-1JC01-0AX0 KP900 精智 9 英寸，按键

150-SPPB1UR SMC-50 POWER POLE ASSEMBLY 90A

1738-IB16DM12 ArmorPoint 16 Point Input Module

1784-CP14 SLC Communication Cable

193-KB40 2.9-4.0 A IEC Bimetallic Overload Relay

20-750-PBAY-RHBB-2437 POWERFLEX 750 KIT,SIDE BUSBAR,2437Amps

2090-CS0DSDS-AA10 Kinetix Cable, 1.0m,Cascade, S0 Safe Off

20AB070A0AYNANC0 PowerFlex 70 AC Drive 70 A at 25 Hp 20A

GA647IFPLSR00150 GCA iFIX Plus SCADA 150 I/O Srv

GP647IFESGCLNTCRN GCP iFIX Optn: ESig & ERec iClient Run

IC600BF832RR 115Vac Input Module (32 points)

IC647HSTCCP10M Historian Client Connection Pack 10 Users (M4 Key)

IC647TDV950 CIMPLICITY HMI Server 5000 I/O Development and Runtime System

IC693MDR390 Mixed I/O, 24Vdc Input (8 points), Relay Output (8 points)

IC756LDV001K-98 DV Development - Intel/Linux RedHat Addt'l User, Korean, Version 9.8

Pico Controllers D1760-GR001BENP PICO CONTROLLER GETTING RESULTS MANUAL

PLC-5/1771 System 1771-OW CONTACT OUTPUT MODULE

Distributed I/O 1791-IOBW BLOCK I/O, 24V DC, 64 PT MODULE

Communications 1786-FS20 200 MICRON CABLE ASSEMBLY 20 METERS (65.6 FT)

Operator Interface 9399-2SE32GRPT RSVIEW32 GETTING RESULTS GUIDE (PORTUGUESE)

Support 9356-PRO2200R SUPT REINSTATEMENT CONTRACT FOR 9356PRO2200

Support 9324-RL0300ITS SUPT RENEWAL CONTRACT FOR 9324RL0300IT

EtherNet/IP Products 1785-L40E ETHERNET/IP PLC-5/40 CONTROLLER, 48K WORD SRAM

RSI Software Products 9301-2SE3500ESU2 RSVIEW32 RUNTIME 1500-100K UPGRADE IN-SUPT (ES)

RSI Software Products 9356-PRO2450U8R UPGRADE: OUT-SUPT: RSSQL PROF.5000 TO 32000 TAGS

Motion Control N-2304-1-F04AA SERV MTR,0.5NM,6000RPM,1000 LN ENCDR,BRK

44A730464-G20 Connector Kit, AC12, A12 & A22/2000 Motor Power

IC200ALG322 ANALOG OUTPUT 12 BIT VOLTAGE +/-10V 4CH

IC693PCM300LTMP Prog. Coproc. Mdl., 160 KB (35 KB Basic Prgm), w/Port Exp. Cbl. Modified for use by OEMs (LT)

Silver Series 6008-SV2R TWO CHANNEL RIO SCANNER FOR VME BUS BACKPLANE

cDAQ-9179

EPIA-PX10000G

PCL-849

EPE-1815VNA-H61

SKYNET ADT-925C

PCA-6002VE

Q965 18204010

1492-SPM1D500 MCB Supplementary Protector 50 A

变频器选件 6SE6 400-0BE00-0AA0 BOP2 操作面板 430

电机启动器 3VU16400MH00

150-CA01 Smart Motor Controller Accessory

1715-A2A 1715 2 Slot Adaptor Base Unit

1771-IR 1771 6 Point Input Module

193-EC4AB E3 Plus 1-5 A Current Relay

198-W103H ModCenter IEC Wiring Kit

2090-CPWM4DF-16AF03 MP-Series 3m Power Cable

2094-BL02 Kinetix Line Interface Module

DEMOCD00010 Proficy FIX DEMO CD

GFK-0732 ECLiPS English Control Language Programming System for Series 90-30 PLC User's Guide

IC210BDR012 24VDC Power Source, (6) 24VDC in /(4) out (Relay 8 Amp), (2) analog inputs, Expandable, without LCD/Keypad

IC647ARC999 PA Reporting Client UNL

IC647PPSOC3 Proficy Process Systems Operator Console with CIMPLICITY - 3 Pak

IC693CPU311 5-Slot Base With CPU in base (6K Bytes User Program) Battery included

IC754VBL06CTD 6 inch TFT QuickPanel View/ Loaded/ 24VDC/ Blank Label

MSI-CONNECTOR-43 Historian Connector-43

SLC/1746 System 1746-R12 REPLACEMENT COVERS FOR SLC 5/01 PROCESSOR MODULES

Distributed I/O 1734-OV2E 24V DC 2 CHANNEL SINK OUTPUT MODULE

Application-specific products 1803-EEM20E4 EEM,32 PULSES, 24V DC, NEMA 4 ENCLOSURE

Operator Interface 2711E-K10C15 PANELVIEW 1000E KEYPAD TERMINAL, 10.4" FLAT PANEL

Support 9302-BATR SUPT REINSTATEMENT CONTRACT FOR 9302BAT

Support 9381-PP2500KENS SUPPORT RENEWAL CONTRACT FOR 9381PP2500KEN

DeviceNet Products 1791D-4B4P DNET 24VDC CBLOCK I/O, 4 IN SINK 4 OUT SOURCE,BASE

RSI Software Products 9301-2SE3350ESU2 RSVIEW32 RUNTIME 300-5K UPGRADE IN-SUPT (ES)

RSI Software Products 9358-PBPCNT60ENE RSBATCH NT FOR PROCESLGIX PC BASED PHASES 60 UNITS

Motion Control MPL-B860D-SJ22AA MOTOR,SERVO,83.0NM,2000RPM,SINGL,460V

Silver Series 1398-DDM-009 DRIVE,15A PEAK, ULTRA 100

HE660BGM224 Genius BASIC Programmable Co-processor with (2) RS-232 ports

IC646TJT000 CIMPLICITY?Tracker Server-Intel

QBH2D100S2P/B QUICKPANEL 6" STN HAND HELD BUNDLE BLANK

ST-2852 STXi output module Triac Output 2 points, 12V ~ 125VAC/ 0.5A

USB-4065

全长CPU卡 IB700

MOXA 摩莎 CP-118U

NEAT-845GVE

DAQ-PCI-4816

DAQ-PCI64C

1492-RIFM20F-2 Connection Products

总线插头 6GK1500-0FC00 RS485 总线插头， 12MBd180? ，连接 OP 及 OLM

变送器 3RS21 40-2GD60

1497A-A1-M18-0-N 50Va 208/230/480-120/24V 50/60 Hz Cpt

1606-XLP100E Power Supply XLP 100 W Power Supply

1764-MM2 MicroLogix 1500 Memory Module

188-K4B130 Miniature Circuit Breaker 13 A

194L-HE6A-375 194L Control And Load Switch Actuator

2090-CPBM7DF-08AF25 25 m Length SpeedTec Flexible Cable

2090-XXNPMF-16S25 Kinetix Drives 25m Standard Cable

CA-860-2 LMI Adapter to GP-3102NT GagePort.

GC647SDL001 GCScheduler Doublet license for PC user

IC200PKG101 I/O starter kits, Genius NIU

IC646TBAPC002 Back-up Server for Advanced Process Control

IC647NCL000 CIMPLICITY HMI Action Calendar Option

IC690CBL710 CIMPLICITY 70 RGB Video Cable

IC697VSC096 Single Board Computer, with 32Mbyte SDRAM & 96 Mbyte Flash. NO OPERAT ING SYSTEM PRE LOADED

IC800VMA012 100 W VersaMotion servo amplifier

SLC/1746 System 1746-C16 CHASSIS INTERCONNECT CABLE, 4FT (1.22M)

Industrial Computers 6181P-17TPXPH VERSAVIEW INTEGRATED DISPLAY COMPUTER 17-INCH TFT

Application-specific products 9358-PBPC10ENE RSBIZWARE BATCH FOR PLX PC BASED PHASE 10 UNITS

Operator Interface 2711-K5A3 PV550 MONOCHROME KEY, DH485 & RS232 PRINT

Support 9301-2SE2100JPS SUPT RENEWAL CONTRACT FOR 93012SE2100JP

Support 9500-CPAKPMENR SUPT REINSTATEMENT CONTRACT FOR 9500CPAKPMEN

ControlNet Products 2711P-RN15S CONTROLNET COMMUNICATIONS MODULE

RSI Software Products 9301-2SE2503ESE RSVIEW32 WORKS 100K WITH RSLINX (SPANISH)

RSI Software Products 9358-BEPNT60ENE EPROCEDURE FOR NT 60 UNITS

Motion Control MPL-A520K-SJ24AA MOTOR,SERVO,10.7 NM,4000RPM,SINGL,230V,BRK,13.9KG

Motion Control 2090-XXNPMP-14S20 CABLE,NON-FLEX,MOTOR POWER,MP/1326AB,14 GAUGE,20M

GABK3D200C2P/SR QUICKPANEL 6" TFT W/SER GE LABEL

IC641SWM313 Logicmaster 90-30 TCP/IP-Ethernet, Cable & Paper Manuals

IC800SSI228D2 28 Amp S2K Series Servo Amplifier/Controller with DeviceNet, 230 VAC

PSPC-ADMIN50/E Prof Shop Floor SPC Admin 50 Usr w/ eSig

PXI-6513

X34PI-1.00

SOM-5786

FSP460-60PFN

FSP300-60GTB

WADE-8656-J2

1492-MS6X12V1-END Connection Products

数字量输入/输出模块SM 6ES7 321-1BL00-0AA0 DI/32 24VDC，光电隔离，40pin 前连接器

行程开关 3SE53122SE12

运行版软件 6AV2105-2DD04-0AC0 SIMATIC WinCC Runtime 专业版 Powerpack Runtime Advanced 512 PowerTags -> Runtime 专业版 512 PowerTags V14

1585J-M8CBJM-0M6 RJ45 Ethernet Media

1756-PB72 ControlLogix 24V DC Power Supply

188-K1D005 Miniature Circuit Breaker 0.5 A

194E-Y100-1753-6G 100 A 194E Load switch

2090-CFBM7DF-CEAF40 Kinetix 40m Flexible Cable

2090-UXNFBMP-S07 MP-Series 7 m Length Feedback Cable

BC646TDV915 Server 1500 I/O Develop/Runtime System with Proficy GlobalCare

GC647IFESGRN00300 GCC iFIX Optn: ESig & ERec 300 I/O Run

IC200ALG620LT ANALOG INPUT 16 BIT RTD 4CH (LT)

IC646MDA700 View Development/Runtime 700 I/O

IC647IFPRRN00900K iFIX Profsnl SCADA 900 I/O Runtime (M1 Kit Part)

IC660TBA105 Terminal Assembly for IC660BBA105

IC697CHS791RR Series 90-70, 9 Slot Rack, Front Mount

IC800MCUB12160XDRR Stepping MotorCube 50 oz-in, DeviceNet

ControlLogix/1756 System 1756-IB16 10-31 VDC INPUT 16 PTS (20 PIN)

Industrial Computers 6182H-7TRH15B VVCE 700, TOUCH, STD MEM, CNET, AC

Process Control 9358-PBEPB60ENE RSBIZWARE BATCH & EPROCEDURE BNDLE PLX 60 UNITS

Operator Interface 2711P-RAK12E PVP/VVCE1250 KEY/COMB TO PV1200/1400E KEY ADAPTER

Support 9352-WM9300R SUPT REINSTATEMENT CONTRACT FOR 9352WM9300

Support 9330-RSRRTENR SUPT REINSTATEMENT CONTRACT FOR 9330RSRRTEN

ControlNet Products 1786-TNCL10 CONTROLNET TNC COAXIAL CONNECTOR - PLUG

RSI Software Products 9301-2SE235JPU2R RSVIEW32 WORKS 300-5K UPGRADE OUT-SUPT (JP)

RSI Software Products 9355-WABCEU2R UPGRADE: OUT-SUPT: 9351WKTS TO RSLINX C SDK CD

Motion Control MPL-A310F-SJ24AA MOTOR,SERVO,1.58 NM,3000RPM,SINGL,230V,BRK,4.1KG

Motion Control 2090-DANFCT-S02 CABLE, NF, MTR FBACK FOR CABLE-MTD CONN, T, 02M