G45X2DUAL-BF现货 in stock! 欢迎来电咨询~！！

G45X2DUAL-BF,

G45X2DUAL-BF

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

PS2668 22N-700AACL

Nipron BU-300P-24P ENSP-300P

AVAYA 电源 G0111A

PCM-1823

WHNC-006A

UNOB-1110MB

1492-RCDA4D25 Residual Current Device 25 A

软启动器 3RW30272BB04

软启动器 3RW44586BC35

运行版软件 6AV2103-0DA00-0AM0 SIMATIC WinCC 专业版 512 PowerTags (Compact Edition)

1585D-M8UGJM-40 Gigabit Ethernet Media

1756-M02AS ControlLogix Analog SSI Motion Module

180040-A01 KIT BUS CONTROL CARD

194E-FA40E 194E Load switch

2090-CFBM7DD-CEAF07 Kinetix 7m Flexible Cable

2090-U3BB-DM12 Ultra 3000 Breakout Board Kit

BC646MRA000 View Runtime 8000 I/O with Proficy GlobalCare Complete

GC647ARC050 GC Reporting Client 50 Pak

I5T/2 Proficy Process Systems Tuning Tools from ControlSoft for 10 Loops

IC646APS30005 CSense Predictive Soft Sensor 5 KPI's

IC647IFPLRN00075C iFIX Plus SCADA 75 I/O Runtime (M1Component Part)

IC660HHC005 Hand-Held Monitor Cable

IC697ACC805 I/O Cable (64 conductor) for IC697Vxxxxx modules. Ten feet long

IC756XDV010E-925 "DV-Draw Development on Solarisx86 Op Sys, English v9.25"

FlexLogix System 1794-TB3S FLEX I/O TERMINAL BASE WITH SPRING CLAMPS

GuardPLC Systems 1753-L28BBBM GUARDPLC 1600 - SAFETY PLC W/MODBUS, 28 I/O

Process Control 1757-UPGSIFG UPGRADE HW UDC 3000/5000/6300 QUICKBUILDER I/F

Operator Interface 2711P-K12C4D1 PV PLUS 1250, KEYPAD, RIO/DH, DC PS, STD MEM

Support 6008-SQS1S SUPT RENEWAL CONTRACT FOR 6008SQS1

Support 1400-SPR 1400-SP SOFTWARE SUPPORT REINSTATEMENT

Support F1785-L80C15SERF FIRMWARE UPGRADE FOR 1785-L80C15 PLC5 PROCESSOR MO

RSI Software Products 9301-2SE2350ESU1 RSVIEW32 WORKS 150-5K UPGRADE IN-SUPT (ES)

RSI Software Products 9701-VWSS250DEU1 RSVIEW SE 25 TO 250 DISPLAY UPGRADE (GERMAN)

RSI Software Products 9399-WAB32GR RSLINX GETTING RESULTS GUIDE

Motion Control 8720MC -B042-AN- 42 AMP B CHASSIS DRIVE, OPEN ENCL., LESS OPTIONS

BC646MPSU01 Logic Developer PLC Standard Edition with SAFE

IC300OCS301 OCS300 5.7" STN WITH ETHERNET

IC752WTD802 Display Station 2000 Series - 18.1" active matrix SXGA (1280x1024) resistive touch screen, Pentium 233 Mhz, 64 MB RAM, 6.4 GB HD, expansion slots, Ethernet, with unlimited point count CIMPLICITY HMI R&D and Win NT

MTR-3T43-J-R-0-M-0RR Servo Motor Metric

PCI-6519

AIO486

NORCO-840AE

Nipron PC1U-210P-X2S

NORCO-690

AIMB-780QG2

1492-L4T IEC Term Blck 6.1x84x35.7mm Spr Clp

1494C-DJX622-A5-B1-D-E 200 A Flange Mtd Cable Switch

软启动器 3RW44342BC34

电源 6ES7 505-0KA00-0AB0 PS：25 W，额定输入电压 DC 24 V

1585BZ-F8BF 1585 Ethernet Media Accessory

1747-L542 SLC 5/04 32K Controller

1791ES-IB16 Guard I/O 16 Point Digital Input

194E-AA00E 194E Load switch

2071-AP1 Kinetix 3 100W Component Servo Drive

2090-CSWM1DF-14AA02 Kinetix Cable Single DSL 2090-Series

20AC1P3C3AYNAEC0 PowerFlex 70 AC Drive 20A

GC646MDC700 Proficy GlobalCare Complete for Logic Developer - PC & View Development/Runtime 700 I/O

HE693DLL308 PCIF-30 Windows DLL, multi-license (8)

IC600WD005 Expansion Rack I/O Cable, 5 feet (1.5m)

IC647HSTESEO75KM eSignature Option for Historian - Enterprise Server 75000 Points (M4 Key)

IC655PWR501RR Power Supply, 12 Amp, 115/230Vac

IC694MDL646CA Conformal Coated Input module 24 VDC 16 point POS/NEG logic. 1msecond filtering.

IC756WDC009E-26 DV Dev Sys VB, Java, C++, Eng v2.6

MicroLogix 1500/1769 System 1764-RPLTB1 REMOVABLE TERMINAL BLOCK KIT (17 PT)

PLC-5/1771 System 1784-CP5 CABLE ASSY, 10FT/3.20M, 1784-KTK1 (15-PIN D-SHELL)

Distributed I/O 1797-TCAP CONTROLNET EX TAP (DUMMY) TERMINATOR (5 PIECES)

Communications D5000-6.6.1 PI DATA TALBE LIBRARY INSTALLATION & CONFIGURATION

Support 9321-L5160R SUPT REINSTATEMENT CONTRACT FOR 9321L5160

Support 9358-EP60S SUPT RENEWAL CONTRACT FOR 9358BEPNT60ENE

Support F1771-VHSCSERB FIRMWARE UPGRADE FOR 1771VHSC I/O MODULE

RSI Software Products 9324-RLD2U7PTE RSLOGIX 5000 MINI TO PRO UPGRADE, PORTUGUESE

RSI Software Products 9304-WVPD300DU2R UPGRADE: OUT-SUPT: WINVW 256 TO WINVW PRO DEV 3000

RSI Software Products 9358-PLTM2500U4R UPGRADE: OUT-SUPT: PLANTMETRICS 50 TO 100 WORKCELL

Motion Control 8720SM-063S5QAS4 63 KW/117.5 AMP, 750 VDC, MOTOR W/SNS60,+MPL

A06B-0033-B175#7008 B3/3000 Servo Motor, Holding Brake, 32K Serial Encoder

IC200TBX223 Tool box, 23 point, (IC200UAL006) 24VDC In/Relay Out, requires 120VAC Power, VersaMax SE (IC200SET001) with all software, cables (IC640VPS002)and manuals.

IC698PSA350 RX7i PLC Power Supply, 85 to 264 VAC at 47 to 63 Hz Input, 350 Watt output

MTR-1350-E-D-E-0RR Stepping Motor Nema34 Encoder

NI 9201

JUKI-745E

cPCI-6840V

BM-VP04

PCA-6187

pci-gpib IEEE 488.2

PROX1720L

1492-SPM3C100-N MCB Supplementary Protector 10 A

软启动器 3RW40472TB04

模拟量输出模块 ES7 232-4HB32-0XB0 SM 1232 AQ 2x14 位

150-SB2NBR SMC-50 SOLID STATE MOTOR CONTROLLER 110A

1734-PDN POINT I/O DeviceNet Interface Module

1783-MCF Stratix 8000 CompactFlash Spare Card

193-ESM-IG-30A-C55 E300/E200 30 Amp Sensing Module

20-750-I1B-C460D430 PowerFlex 750 Replacement Inverter

2090-CPWM7DF-14AF25 MP-Series 25m Length Power Cable

2098-DSD-HV150-DN Ultra 3000 Servo Drive

GA647IFCLNTCDV GCA iFIX iClient Dev

GP-0602NT-F8 GagePort LVDT NT (Full Bridge for Sangamo A6G1, Standard E4-8030)

IC5005CAC0001 PanelClient 15 inch with iFIX Terminal Service License

IC647HSTAE2000KM Alarm and Events Option for Historian - Standard Server 2,000,000 Points (M4 Key)

IC647SPT001 Scheduler Proficy Plant Apps Adapter

IC693MDL733RR 12/24 Vdc Output, 05 Amp, Negative Logic (8 Points)

IC756HDV001K-99 DV Development - HP/UX Op Sys Addt'l User, Korean, Version 9.9

Pico Controllers 1760-L12AWA-NC 12 I/O PICO CONTROLLER, AC

PLC-5/1771 System 1771-IN INPUT MODULE, 24V AC, 8 INPUT

Distributed I/O 1791D-4B0 DNET 24VDC CBLOCK I/O, 4 IN SINK (NOT EXPANDABLE)

Communications 1784-PCM6 1784-PCMK DH+COMMUNICATION CABLE(8 PIN DIN)

Operator Interface 2706-P44R INVIEW MESSAGE DISPLAY. 1 OR 2 LINE

Support 9305-RSVADSJPS SUPT RENEWAL CONTRACT FOR 9305RSVADSJP

Support 9515-RSMCLT010S SUPT RENEWAL CONTRACT FOR 9515RSMCLT010EN

EtherNet/IP Products 2711-K10G20 PV1000 GRAYSCALE KEY, ENET & RS232 PRINT

RSI Software Products 9301-2SE340DEU1R RSVIEW32 RUNTIME 1500-32K UPGRADE OUT-SUPT (DE)

RSI Software Products 9356-PRO2200U2R UPGRADE: OUT-SUPT: RSSQL STD.300 TO PROF.300 TAG

Motion Control 1326AB-B720E-S2K7L MOTOR,SERVO,460V,30.9NM,3500RPM,SINGL,BRK,IP67

4161-6-5 BCD To 7 SEG Display . 6 Digit, 5VDC. Dust Seal

HMI-CCT-303 BACKLIGHT TUBE 6" STN or MONOCHROME LCD QPK3 Series QPK-3xxxx-Sxx or Lxx)

IC693CPU323 10-Slot Base With Turbo CPU in base (.6 msec) 12K bytes User Program

SFW-TGTP-1.2 Target Program Flash Memory Card Rev 1.2

PCM-9562D

TREX-755

EICON EiconCard C21

NuPRO-595/596

IPC06VM1500034

ASC486

8002-4104

1492-SPM1C400-N MCB Supplementary Protector 40 A

通用型变频器 6SE6 440-2UC15-5AA1 0.55 KW,73 x 173 x 149

电机启动器 3VU13402ML00

150-C251NCD SMC-3 251A Smart Motor Controller

1609-B1000N Bul 1609 AC to AC UPS 600W Power Supply

1770-KFD RS-232C to DeviceNet Interface Module

193-EC1BD E3 3-15 A Overload Relay

194R-TL3 194R 400 Amp Multi-tap Terminal Lugs

2090-CPBM7E7-10AF07 MP-Series 7 m Length Pwr and Brake Cable

2093-AM01 Kinetix 2000 Axis Module

CP6B-0WPB-0070-AZ Power cable for B22/2000is motor. 7 meters

GF-AU10V Connecting FlashCable to Analog Unipolar +10 V (No connector),

IC200UEX014 14 point Exp (8) 24VDC In, (6)24V DC Out, 24VDC Power Supply (includes IC200CBL501)

IC647AEC002 PA Efficiency Client 2 Pak

IC647PCM050 Proficy Change Management Server - 50 Concurrent Users

IC693CBL330 Cable, Right Side, Two - 24 Pin 90 Degree Connectors, 1 Meter

IC754CBF08CTD Control Fully Loaded 8 Inch TFT Blank

IMC-31PE-2-DRR IMC-D Series Servo Motor Controller, Enhanced, 24 Amp

SLC/1746 System 9399-RSRGR RSRULES GETTING STARTED GUIDE

Distributed I/O 1732D-8CFGM12 DEVICENET 24VDC 8 SELECTABLE POINTS W/M12

Application-specific products 1404-M805B-000 MASTER MODULE-PQ-24V P/S

Operator Interface 2711-K10G9 PV1000 GRAYSCALE KEY, RS232 (DH485) & RS232 PRINT

Support 9301-2SE3400DER SUPT REINSTATEMENT CONTRACT FOR 93012SE3400DE

Support 9381-P500ENS SUPT RENEWAL CONTRACT FOR 9381P500EN

DeviceNet Products 1790-8BV8BX LDX I/O, 24VDC, 8 UNIV IN/8 SRCE OUT EXPAN D-SHELL

RSI Software Products 9301-2SE3300PTU1 RSVIEW32 RUNTIME 300-1500 UPGRADE IN-SUPT (PT)

RSI Software Products 9358-EPBKY03ENE RSBIZWARE EPROCEDURE BACKUP KEY 3 UNITS

Motion Control MPL-B520K-MJ22AA MOTOR,SERVO,10.7 NM,4000RPM,MULTI,460V,11.3KG

Motion Control 9101-0403 CONNECTOR KIT, MOTOR BRAKE, F/H, 90 DEG

GQPJ2D100S2P QUICKPANEL JR. COLOR 5" STN GE LABEL

IC646MRC700 Logic PC & View 700 Tag Runtime System

MTR-3T21-G-R-B-M-S MTR-Series Servo Motor, Resolver, Metric, 24 Brake, Seal

SNAP 10C5 PC Port is 9-pin male and port on CNC is 9-pin female. This is for Xo n/Xoff communications.

PXIe-8430/16

813-049-01

PMPC-2

IMB-9454G-R2

02-15787-02

XMC-PO04A-PCI

1492-PRINTINK-K Clear Mark Printer Black Ink Cartridge

连接电缆 6ES7468-1AH50-0AA0 IM 电缆，0.75m

变送器 3RS11002CD20

1497-E-BASX-0-N Control Circuit Transformer

1606-XL480E-3 Power Supply XL 480 W Power Supply

1762-L24BWA MicroLogix 1200 24 Point Controller

188-K3C400 Miniature Circuit Breaker 40 A

194L-G3572 194L IP66 ABS Thermoplastic Enclosure

2090-CPBM7DF-04AA40 MP-Series 40 m Length Cable

2090-XXNFY-S15 Y-Series 15 m Length Feedback Cable

BC647SPPMK01 Solution Provider Plant Apps M4 Key includes 1 physcial M4 key that authorizes Plant Apps as well as all core products

GC647PPSOPC Global Care for Proficy Process Systems EGD OPC Server

IC200MDL640LT INPUT 24VDC POS/NEG LOGIC (2 GROUP OF 8) 16PT (LT)

IC646PCM100 Proficy Change Management 100 user pack

IC647MPP050 Logic Developer PLC Professional 50 pack with USB Hardware key

IC676CBLPWM020 IP67 Power Cordset - 2 Meters - Male Connector w/Leads

IC697PWR710RR Power Supply, 120/240 Vac, 55 Watts

IC800SSI107RD2RR 7.2A, 115/230V, DeviceNet S2K Servo Controller for MTR Series Motors

SLC/1746 System 1747-L20B 20 I/O FIXED HARDWARE STYLE

Industrial Computers 6189-RDT12C VVCE 1250 TOUCH SCREEN DISPLAY MODULE

Process Control 9399-RSBSAPRG RSBATCH SERVER API REFERENCE GUIDE

Operator Interface 2711-B5A2L2 PV550 MONO KEY&TOUCH, DH485

Support 9303-3CS0E10S SUPP RENEWAL CNTRCT FOR 9303-3CS0E10

Support 9371-RSWD1S SUPT RENEWAL CONTRACT FOR 9371RSWD1

ControlNet Products 2706-P72CN1 INVIEW MESSAGE DISPLAY. 1 TO 4 LINE

RSI Software Products 9301-2SE2500ITU1 RSVIEW32 WORKS 32K-100K UPGRADE IN-SUPT (IT)

RSI Software Products 9358-BBBKY60ENE RSBIZWARE BATCH, EPRO BUNDLE BACKUP KEY 60 UNITS

Motion Control MPL-A4530K-HJ22AA MOTOR,SERVO,8.36NM,4000RPM,ENCDR,230V,8.2KG

Motion Control 2090-UXNPBMP-8S30 CABLE,460V,NON-FLEX,MOTOR POWER,MP,8 GAUGE,30M

CBL-3T-MP-30 Power Cable, MTR-3T4x, MTR-3T5x & MTR-3T6x Series Servo Motors, 30 Ft.

IC641CTL995 Media Kit

IC800SLM350M2XE25 3500W, 230 VAC SL Servo Motor, Holding Brake, 2.5K Quad Encoder

OC647TSSOPCC000 Proficy Troubleshooter Connector: OPC Client Read & Write (including OPC HDA)

PXI-5152

PX-10S-RS-R30

LAMBDA UAZ1EP 400W UAZXEXPX0000 9940

AC6650

ICPMB-8650GR-R12

METEOR2-DIG/4/L

1492-MCGAT230 Ground Fault Circuit Breaker

1494V-L2 Door Hardware Kit

软启动器 3RW44656BC36

运行版软件 6AV2104-2HK04-0BD0 SIMATIC WinCC Runtime Advanced Powerpack 4096 PowerTags -> 8192 PowerTags V14

1585J-M4TBJM-0M15 RJ45 Ethernet Media

1756-OB16D ControlLogix 16 Pt 24V DC D/O Module

188-K1B250-N Miniature Circuit Breaker 25 A

194E-FA80 194E Load switch

2090-CFBM7DF-CDAF04 MP-Series 4m Feedback Cable

2090-U5EK-DN Ultra 5000 Breakout Board Kit

BC646MVD000 ME View View OPC Driver License w/Global Care and Software Key

GC647AUR002 GC Universal Reporting Client 2 Pak

IC200ACC403 Battery for 23 and 28 point Micro for data retention

IC646CSPR001 Proficy Cause+ for Intelligent HMI/SCADA Runtime Server - 1X monitored KPI

IC647IFPLRNUNLMTM iFIX Plus SCADA Unlimited Runtime (M4 Part)

IC660MLA101 Label for IC660BBA101 (Qty 100)

IC697ALG440RR Analog Input Expander, Current, 16 Channels

IC758WMM010 iGlobalCare Complete 6-10 Users (same site): DataViews for Windows

FlexLogix System 1794-CE1 EXTENDER CABLE FOR TERMINAL BASES, 1FT/.3M

GuardPLC Systems 1755-OF8 GUARDPLC 2000 - ANALOG OUTPUT MODULE

Process Control 1757-UPGSIFW UPGRADE MA500 QUICKBUILDER I/F

Operator Interface 2711P-T12C6B1 PV PLUS 1250, TOUCH, RIO/DH, AC PS, STD MEM

Support 9220-TAS SUPT RENEWAL CONTRACT FOR 9220TA

Support 2755-ASNR SUPT REINSTATEMENT CONTRACT FOR 2755ASN

Support F1785-V30BSERC FIRMWARE UPGRADE FOR 1785-V30B PLC5 PROCESSOR MODU

RSI Software Products 9301-2SE2350JPU3 RSVIEW32 WORKS 1500-5K UPGRADE IN-SUPT (JP)

RSI Software Products 9701-VWSTFRU1 RSVIEW STUDIO FOR ME - ENT SERIES UPGRADE (FRENCH)

RSI Software Products 9399-WAB32UGPT RSLINX USERS GUIDE (PORTUGUESE)

Motion Control 8720MC -D180-AA- 180 AMP D CHASSIS DRIVE, ENCLOSURE, LESS OPTIONS