DG130R-ARBS-2

主要产品：日本东方马达，韩国DKM减速电机，泰映TROY减速电机，韩国SPG小功率

马达，CPG晟邦减速电机 ...

销售热线: 180-6090-9625/0592-6013512

联系人：兰工

      QQ: 869740621

减速机技术资料：

在选择减速机的型号时应注意的几个事项：尽量选用接近理想减速比：减速比=伺服马达转速/减速机出力轴转速扭力计算：对减速机的寿命而言，扭力计算非常重要，并且要注意加速度的最大转矩值（TP），是否超过减速机之最大负载扭力。
适用功率通常为市面上的伺服机种的适用功率，减速机的适用性很高，工作系数都能维持在1.2以上，但在选用上也可以以自己的需要来决定，要点有二：A.选用伺服电机的出力轴径不能大于表格上最大使用轴径；B.若经扭力计算工作，转速可以满足平常运转，但在伺服全额输出时，有不足现象时，我们可以在电机侧之驱动器，做限流控制，或在机械轴上做扭力保护，这是很必要的。
通用减速机的选型包括提出原始条件、选择类型、确定规格等步骤。
相比之下，类型选择比较简单，而准确提供减速器的工况条件，掌握减速器的设计、制造和使用特点是通用减速器正确合理选择规格的关键。
规格选择要满足强度、热平衡、轴伸部位承受径向载荷等条件。
1.按机械功率或转矩选择规格（强度校核）通用减速器和专用减速器设计选型方法的最大不同在于，前者适用于各个行业，但减速只能按一种特定的工况条件设计，故选用时用户需根据各自的要求考虑不同的修正系数，工厂应该按实际选用的电动机功率（不是减速器的额定功率）打铭牌；后者按用户的专用条件设计，该考虑的系数，设计时一般已作考虑，选用时只要满足使用功率小于等于减速器的额定功率即可，方法相对简单。
通用减速器的额定功率一般是按使用（工况）系数KA=1（电动机或汽轮机为原动机，工作机载荷平稳，每天工作3~10h，每小时启动次数≤5次，允许启动转矩为工作转矩的2倍），接触强度安全系数SH≈1、单对齿轮的失效概率≈1%，等条件计算确定的。
所选减速器的额定功率应满足：PC=P2KAKSKR≤PN式中PC———计算功率（KW）；PN———减速器的额定功率（ KW）；P2———工作机功率（KW）；KA———使用系数，考虑使用工况的影响；KS———启动系数，考虑启动次数的影响；KR———可靠度系数，考虑不同可靠度要求。
目前世界各国所用的使用系数基本相同。虽然许多样本上没有反映出KS\ KR两个系数，但由于知己（对自身的工况要求清楚）、知彼（对减速器的性能特点清楚），国外选型时一般均留有较大的富裕量，相当于已考虑了KR\ KS的影响。
由于使用场合不同、重要程度不同、损坏后对人身安全及生产造成的损失大小不同、维修难易不同，因而对减速器的可靠度的要求也不相同。系数KR就是实际需要的可靠度对原设计的可靠度进行修正。它符合ISO6336、GB3480和AGMA2001—B88（美国齿轮制造者协会标准）对齿轮强度计算方法的规定。目前，国内一些用户对减速器的可靠度尚提不出具体量的要求，可按一般专用减速器的设计规定（SH≥1.25，失效概率≤1/1000），较重要场合取KR=1.25=1.56左右。
2、热平衡校核通用减速器的许用热功率值是在特定工况条件下（一般环境温度20℃，每小时100%，连续运转、功率利用率100%），按润滑油允许的最高平衡温度（一般为85℃）确定的。条件不同时按相应系数（有时综合成一个系数）进行修正。
所选减速器应满足：PCt=P2KTKWKP≤Pt式中 PCt———计算热功率（KW）；母线加工机KT———环境温度系数；KW———运转周期系数；KP———功率利用率系数；Pt———减速器许用热功率（KW）。
3.校核轴伸部位承受的径向载荷通用减速器常常须对输入轴、输出轴轴伸中间部位允许承受的最大径向载荷给予限制，应予校核，超过时应向制造厂提出加粗轴径和加大轴承等要求。

OMRON C20K-CARA USPP C20KCARA

OMRON C120-PRO15-E USPP C120PRO15E

OMRON C120-PRO15 USPP C120PRO15

OMRON CX-V1.2 USPP CXV12

OMRON CX-V2.0 USPP CXV20

OMRON SCYPOR-CPU10 USPP SCYPORCPU10

OMRON WS02-CXPC1-ESM-V2.1 USPP WS02CXPC1ESMV21

OMRON 3G2A6-PRO15 USPP 3G2A6PRO15

OMRON CS1W-ETN11 NSFP CS1WETN11

OMRON CJ1H-CPU65H ( CJ1HCPU65H ) used

Omron V740-HS03L RFID Reader Writer Antenna * NEW * 
6 brand new units available... satisfaction guaranteed!

CS1W-PDC55 Omron PLC New In Box CS1WPDC55


OMRON FZSC USPP FZSC

OMRON C200H-AD002 USPP C200HAD002

OMRON Z4W-V25R USPP Z4WV25R

OMRON PLC CV1000-CPU01-V1 CPU Unit 

OMRON C500-MD211CN NSFP C500MD211CN

OMRON C28P-EAR-A USPP C28PEARA

OMRON 3F88L-130 USPP 3F88L130

Omron CS1H-CPU64H CS1HCPU64H Processor NEW


Omron CQM1H CPU 61 Controller

Z4LBCV2 NEW OMRON Z4LB CV2 FREE SHIPPING


OMRON C500-AD001 USPP C500AD001

OMRON C28P-CDT1-A USPP C28PCDT1A

OMRON I/O Unit C28P-EAR-A C28PEARA 


CPM2A-60CDR-D12-U1 Omron PLC New Box 60 I/O CPU CPM2A60CDRD12


OMRON CVM1-CPU11-V2 (No key) Free Ship

Omron F10-S30R F10S30R Pattern Matching Sensor - Used


OMRON CS1W-ETN01 USPP CS1WETN01

OMRON C28P-EDR-A NSFP C28PEDRA

OMRON SYSDRIVE INVERTER 3G3MV-CB007 NEW 3G3MVCB007 200V 1 PHASE

OMRON Programmable Controller C60K-CAR-A C60KCARA C6OK-CAR-A C6OKCARA


Omron CJ1H-CPU65H CPU Unit 128K Memory CJ1HCPU65H


Omron CJ1G-CPU43P CPU, LOOP,20K STEPS PROGRAM, 64K Process Unit

OMRON 3G8B3-M0020 BOARD 3G8B3M0020

OMRON CS1W-SLK11 Sysmac Link Unit

Omron HMI NT31-ST123B-EV3 (NT31ST123BEV3) NIB New

Omron CIDRW Controller V700-L22 & CABLES



Omron CIDRW Controller V700-L22 & CABLES

Omron CJ1G-PA202 PSU MD231, SRM21 (2) CLK21-U1

OMRON 41047-1 *RECONDITIONED*

OMRON R88D-UP02HA AC SERVO DRIVER 200/230 VOLT 30 WATT 1.3 AMP 50/60 Hz

C200H-CPU03-E2 Omron PLC New In Box CPU C200HCPU03E2


Omron V600-CA8A-V2 PNP RFID Controller V600CA8A ! WOW !

OMRON CV500-RM221 USPP CV500RM221

Omron, NT30 ST131B V1, Interactive Display

Omron CS1W-PDC55/CS1WPDC55 Isolated 8 Point A/D Module NEW!! SEALED!!!!


Omron ZS-HLDC11 laser controller & ZS-LD80-F sensor

Omron PLC Analog Input Module Programmable Controllers 4 Channel CJ1W-AD041-V1

OMRON C500-RT002-PEV1 NSFP C500RT002PEV1

OMRON C500-PRW06 NSFP C500PRW06

OMRON V600-CA1A-V2 USPP V600CA1AV2

NT20SST121BEU3 NEW OMRON NT20S ST121B EU3 FREE SHIPPING


Omron R7D-AP08H | 12 mo. warranty | Free UK/EU Shipping | Price Inc UK VAT

OMRON AC SERVO DRIVE R88D-WT08H VER. 3C USED R88DWT08H


OMRON C200HS-CPU01-E QUANTITY! SYSMAC CPU PROGRAMMABLE CONTROLLER UNIT

OMRON E5ZE-8AQH01TCB USPP E5ZE8AQH01TCB

Omron C500-GPC01 Graphic Programming Console GPC01 3G2C5-GPC01E C2000-MP304-EV3

OMRON NT20S-ST121B-V1 Touch Panel NIB

Omron NS5-SQ00B-V1 Free Ship

OMRON NT600M-DT211 

Omron Servo Drive R88D-WT08H Free Ship

Omron CS1W-DA08V New in Box Free Ship

Omron CV1000-CPU01-EV1 CV1000-V1 Free Ship

NEW OMRON C200H-CPU02 SYSMAC PROGRAMMABLE CONTROLLER CPU MODULE UNIT 

OMRON CV500-BI111 USPP CV500BI111

OMRON C500-OC224-E NSFP C500OC224E

OMRON C200H-TS101 USPP C200HTS101

Omron C200HS-CPU21E, Used, Fast Shipping

Omron C500-OC223, New, C500OC223, Fast Shipping

Omron CPM2A-40CDR-A, New, CPM2A40CDRA, Fast Shipping

Omron CPM2A-40CDR-D, New, CPM2A40CDRD, Fast Shipping

Omron CPM2A-40CDT1-D, New, CPM2A40CDT1D, Fast Shipping

Omron C40K-CDR-A, Used, C40KCDRA, Fast Shipping

Omron C40K-CDR-D, Used, C40KCDRD, Fast Shipping

Omron C40H-C5DR-DE, Used, C40HC5DRDE, Fast Shipping

NEW OMRON CJ1W-V600C12 ID SENSOR UNIT RFID 

CV1000-CPU01-EV1 Omron PLC CPU CV1000CPU01EV1


Omron NT600M-DT211 NT600MDT211 INTERACTIVE DISPLAY

OMRON F150-SL20 NSFP F150SL20

OMRON C500-OA225 NSFP C500OA225

B500IM211E 3G5A2IM211E NEW OMRON B500 3G5A2 IM211 E


Omron CJ1W-PA202 MD231, ETN21, CLK21-V1, SCU21

Keyence KV-1000 C32XA, C32TA, FL20, L20R

FS Omron NSJ ETN21 Module NSJW-ETN21

Omron C500-CT021 Counter Unit C500CT021


24389 NEW Omron 3F88L-RS15 Resolver Connector 10V 5kHz


Omron Sysmac CJ1W-NCF71 NC Unit Version 2.0 ***EXCELLENT***
OMRON SYSMAC PLC CSIH-CPU65H SET ENT21 CLK52-V1 AD001 TC001 OD219 OD231 ID231

OMRON CS1W-DA041 NSFP CS1WDA041

OMRON 3G2C5-BC001 NSFP 3G2C5BC001

OMRON C200H-LK401 NSFP C200HLK401

OMRON C40H-C6DR-DE USPP C40HC6DRDE

OMRON C500-PS211-E NSPP C500PS211E

OMRON C200HG-CPU53 USPP C200HGCPU53

C500OC224E 3G2A5OC224E OMRON C500 OC224 E 3G2A5 OC224 E


Omron CJ1G-CPU44H CPU Unit Programmable Controller NEW

OKUMA LC10/LR10 OMRON SPINDLE DRIVE DOUBLE CONVERTER SDU-600W E4809-045-019E

Omron 3F88M-116A/3F88M116A Servo Positioner 


Omron R88M-WP20030L-W/R88MWP20030LW BRAND NEW!!!!!


Omron C60H-EDR-D/C60HEDRD NEW!!!!!!


Omron C200HE-CPU42-ZE/C200HECPU42ZE NEW!!! SEALED!!! 


Omron C200H-TV103/C200HTV103 Temperature Control NEW!!!


OMRON C200H-CT002/C200HCT002 Factory Sealed!!!!!!!


NEW!!!!! Omron 3G2S6-CPU29/3G2S6CPU29 NEW!!!!!!!


OMRON R88D-UA20HA USPP R88DUA20HA

OMRON NSJW-ETN21 NSJWETN21 ETHERNET UNITNEW

Omron CJ1W-NC213 CJ1WNC213 NIB Free Ship 

OMRON HMC-ES551 USPP HMCES551

Omron NS5 Touch Screen Program Terminals Automation HMI

OMRON C200H-CT021 USPP C200HCT021

OMRON 3G3XV-A4037-CE NSFP 3G3XVA4037CE

Omron ZFV-R5020 Smart sensor high speed camera automation vision system NEW PLC

Omron PLC Module C200H C200H-ID212 C200H-0C22H C200H-NC112 C200H-LK201-V1 Used

Omron DC Power Supply S8J2-5112 S8J2-5124 Lot of 33 Used Working

New Omron PLC CJ1W-NC213

OMRON 3G3MV-A4007 USPP 3G3MVA4007

OMRON C500-OD415-CN NSFP C500OD415CN

OMRON CV500-BC031 USPP CV500BC031

OMRON C200H-CT001-V1 NSPP C200HCT001V1

OMRON VS650960-M10R USPP VS650960M10R

OMRON R88D-UA08V USPP R88DUA08V

Omron PLC CPU 32 DC input # C60K-CDR-A-3031

Omron 3F88L-160 Cam Positioner NEW 


OMRON / CPU UNIT / C200HS-CPU21-E - USED


OMRON NT30C-ST141-E (NT30CST141E) , DISPLAY, used .

OMRON F3SN-A0457P25-D

OMRON F3SN-A0457P25-L

OMRON KZDY-KFB006-1004A PC BOARD KZDYKFB0061004A

OMRON KZDY-KFB005 PC BOARD KZDYKFB005

OMRON KZDY-KFB023-1005D PC BOARD KZDYKFB0231005D

OMRON POWER SUPPLY DC 24V 27A S82D-6024

Omron C20K-CDR-A


OMRON AC SERVO DRIVER R88D-UA03HA *NEW*


OMRON ANALOG OUTPUT UNIT NEW IN BOX, TYPE CQM1-DA022

OMRON 3G8B3-CS001 BOARD 0287563-7A2

Omron Sysmac CQM1-CPU21-E Programmable Controller CQM1-PA206 Power Supply & Rack


OMRON D5F-2B34C-Y HIGH PRECISION SWITCH/ SENSOR

OMRON D5F-2B34C-Y HIGH PRECISION SWITCH/ SENSOR


Omron C500-CT021 Counter Unit C500CT021


Omron boards W-L00570 FD310-DSB2 for Osacom 6800 C1 Robot Controller for MRH-5

Omron E2CA-AN4D Proximity Sensor Amplifier


C120-AD007 Omron PLC New In Box Analog In 3G2A6-AD007 


C120-AD005 Omron PLC New In Box Analog In 3G2A6-AD005 


F300-A20 Omron New In Box Vision Sensor Card F300A20


F300-FM2 Omron New In Box Vision Sensor Card F300FM2


CJ1M-CPU13-ETN Omron PLC CPU With Ethernet CJ1MCPU13ETN


C200HW-SLK24 Omron PLC New In Box Link Module C200HWSLK24


Omron H8PS-8BFP Cam Positioner 24VDC ! NEW !

NEW OMRON LED DISPLACEMENT SENSOR 12-24V MODEL Z4W-V25R

V500-LPR5627-P Omron Bar Code Laser Scanner For PLC V500LPR5627P


E3MC-X11 Omron Photoelectric RGB Color Mark Sensor E3MCX11


Omron Rotary Encoder E6C3-AN5B new


OMRON Parallel Beam Linear Sensor Z4LBS10V2 Z4LB-S10V2

C28H-C6DR-DE-V1 Omron PLC New In Box CPU C28HC6DRDEV1


C500-ASC04 New Box Omron PLC ASCII Basic Card C500ASC04


(AB01) INTERACTIVE DISPLAY OMRON NT20M-DT121-V2 WORKING

C500-DA101 New In Box Omron PLC Analog Output C500DA101


V680-CA5D02 Omron New In Box ID Controller V680CA5D02


(AE01) OMRON SYSMAC PA204 CS1G CPU44V1 CS1W-SCB21 CS1W-BC053 OD216 OD218

C200HE-CPU42-E Omron PLC New In Box CPU C200HECPU42E


OMRON NT31C-ST141B-EV1 24VDC OP INTERFACE HMI NEW QTY

ZS-LD80 Omron New Laser Sensor ZSLD80


CVM1-CLK12 New In Box Omron PLC Link Module CVM1CLK12


Omron E32-T12F Photo Electric Fiber Switch 2 Meter Brand NEW 2 CT Lot 

C500-DA002 New In Box Omron PLC Analog Out 3G2A5-DA002 C500DA002 3G2C5DA002


OMRON E3MC-X41 PHOTOELECTRIC SWITCH E3MCX41


OMRON C500-AD002 A/D UNIT GOOD TAKEOUT

Omron Sysmac C200HS CPU21 (3)-OC225 (2)-OC224 AD001 IA122 ID211

OMRON C500-AD007 USPP C500AD007

OMRON C500-ZL3AT1-E NSFP C500ZL3AT1E

OMRON CJ1G-CPU42H NSFP CJ1GCPU42H

OMRON E3MC-MY11 NSFP E3MCMY11

OMRON CV500-IC101 I/O CONTROL MODULE ***NIB***

OMRON CJ1W-EIP21 CJ1WEIP21 Ethernet Module NIB FreeShip

Omron Sysmac CS1H-CPU65-V1 CPU Module Free Ship

OMRON K3HB-XAA-BCD1 New in Box Free Ship

BALDOR ASR SERIES BTS10-5/10-24-RL-708 SERVO DRIVE

OMRON Z4LC-C28 PARALLEL BEAM LINE LASER SENSOR

Omron NS5-SQ01-V1-A Free Ship

OMRON NT30C-ST141-E INTERACTIVE DISPLAY NT30CST141E

Omron C200HX-CPU43 Free Ship

Omron C200HW-PCU01 PC card unit

Omron E5ZD-8A02KJ card

OMRON NT20S-ST121-ECV3 HMI NIB FreeShip

Omron PLC Module CJ1W-DA08V CJ1WDA08V New in Box Free Ship

OMRON NT31C-ST141B-EV2 Touch Panel Free Ship

OMRON AC Servo Driver R88D-GT15H-Z 1.5KW Free Ship




Omron NS5-SQ00B-ECV2 Free Ship

Omron CJ1W-II10 CJ1W-SCU21-V1 CJ1W-OC211 CJ1W-OD262 PLC

Omron sysmac C2000H-CPU01-EV1

OMRON F150-C10E-2 Vision Mate Controller Free Ship

Omron C200HX-CPU85-Z CLK21 SRM21 OD219 ID217 PLC

OMRON R88D-HS22 AC SERVO DRIVER Free Ship

Omron Link Terminal Relay Unit B7A-A02 NIB (2984)


NEW OMRON SYSMAC CS1G-CPU44H CPU MODULE (NIB FS) 

OMRON C500-CT012/3G2A5-CT012 COUNTER UNIT ***XLNT***

Omron E5ZD-8A02P card

OMRON E5AK-AA2B Digital Controller New in Box Free Ship

NEW OMRON 3G3MV-C2037, YASKAWA CIMR-V7AM23P7 INVERTER 230VAC 3.7kW 5HP


Omron C1000H-CPU01-EV1 with C2000-MR341-V2

Omron C1000H-CPU01-EV1 with C2000-MR831-V2

Omron C200H-FZ001 Fuzzy unit

OMRON ZFV-SR50 Smart Sensor + ZFV-A10 Amp Unit FreeShip

Omron CS1W-NC213 New in Box Free Ship

Omron NSJW-ETN21/NSJWETN21 Ethernet Unit BRAND NEW!!!!!!!!!!!! 


Omron C200HS-CPU21 CPU unit

Jetter 9710014121 E-INT5 INT5 V1.01/1.01 Omron NEW Jetter Prozess-SPS 

OMRON V530 - R160 2D CODE READER USED

Omron CS1W-PDC55/CS1WPDC55 Isolated 8 Point A/D Module BRAND NEW!! 


Omron C500-CT021 C500CT021 Counter Unit

Omron C200H-NC413 New in Box free ship

Omron R88D-GN01L-ML2 AC Servo Driver Free Ship

E2CDC1R5C3A NEW OMRON E2CD C1R5C3A FREE SHIPPING


OMRON E4DA-WL1C USPP E4DAWL1C

OMRON R88M-W75030H AC SERVO MOTOR 750W 200V 4.4A R88MW75030H 

OMRON G730-R0C16-B REMOTE TERMINAL OUTPUT ***NIB***

Omron C200HX-CPU44 New In Box Free Ship

OMRON C500-ASC01 USPP C500ASC01

OMRON C500-DA002 USPP C500DA002

Omron CQM1-CPU41-EV1 | 12 mo. warranty | Free UK/EU Shipping | Price Inc UK VAT

OMRON F3SN-A0603P14-L Sensors used

OMRON F3SN-A0603P14-D Sensors used

Omron SMARTSTEP R7D-AP02L R7M-A20030-BS1 R7G-RGSF05B200 (Shimpo - RGSF) (26)

Omron NT20S-ST121B-V1 Interactive Display Touch Screen 24VDC 10W *Tested*

New Omron PLC Module C200H-CT021

Omron 8 Slot Rack PLC w C200HE PA204 C200HW-CEO01 (3555)

OMRON C28K-CDS1-A NSFP C28KCDS1A

OMRON V600-CA1A USPP V600CA1A

OMRON V600-CA2A USPP V600CA2A

OMRON S82D-6005 USPP S82D6005

Omron C200HE-CPU32-E/C200HECPU32E/C200HE-CPU32 SEALED!!


New Omron PLC CJ1G-CPU42H