VHR590A-25JG

VHR590A-25U

主要产品：日本东方马达，泰映TROY减速电机，韩国SPG小功率马达，

韩国DKM减速电机,CPG晟邦减速电机 ...

销售热线: 180-6090-9625/0592-6013512

联系人：兰工

      QQ: 869740621

减速机技术资料：

减速机是一种动力传达机构，利用齿轮的速度转换器，将电机(马达)的回转数减速到所要的回转数，并得到较大转矩的机构。在目前用于传递动力与运动的机构中，减速机的应用范围相当广泛。下面让万贯五金机电网的小编带您一起了解一下蜗轮蜗杆减速机常见问题及其原因：
(1)减速机发热和漏油
(2)蜗轮磨损
(3)传动小斜齿轮磨损
(4)轴承(蜗杆处)损坏
1、减速机发热和漏油
蜗轮减速机为了提高效率，一般均采用有色金属做蜗轮，采用较硬的钢材，由于它是滑动摩擦传动，在运行过程中，就会产生较高的热量，使减速机各零件和密封之间热膨胀产生差异，从而在各配合面产生间隙，而油液由于温度的升高变稀，容易造成泄漏。
主要原因有四点，一是材质的搭配是否合理，二是啮合磨擦面的表面质量，三是润滑油的选择，添加量是否正确，四是装配质量和使用环境。
2、蜗轮磨损
蜗轮一般采用锡青铜，配对的蜗杆材料一般用45钢淬硬至HRC45一55,还常用40C:淬硬HRC50一55，经蜗杆磨床磨削至粗糙度RaO.8fcm,减速机正常运行时，蜗杆就象一把淬硬的“锉刀”，不停地锉削蜗轮，使蜗轮产生磨损。
一般来说，这种磨损很慢，象某厂有些减速机可以使用10年以上。如果磨损速度较快，就要考虑减速机的选型是否正确，是否有超负荷运行，蜗轮蜗杆的材质，装配质量或使用环境等原因。
3、传动小斜齿轮磨损
一般发生在立式安装的减速机上，主要跟润滑油的添加量和润滑油的选择有关。立式安装时，很容易造成润滑油油量不足，当减速机停止运转时，电机和减速机间传动齿轮油流失，齿轮得不到应有的润滑保护，启动或运转过程中得不到有效的润滑导致机械磨损甚至损坏。
4、蜗杆轴承损坏
减速机发生故障时，即使减速箱密封良好，该厂还是经常发现减速机内的齿轮油已经被乳化，轴承已生锈、腐蚀、损坏，这是因为减速机在运停过程中，齿轮油由热变冷后产生的水分凝聚造成;当然，也和轴承质量，装配工艺方法密切相关。

KLOCKNER MOELLER ZB4-209-DS2 NSFP ZB4209DS2

Klockner Moeller Easy Relay PLC - I/O

Klockner Moeller Easy Relay PLC

Klockner Moeller Contactor DIL M300 AC or DC 110 or 250V Coil 125 HP @ 230V

Klockner Moeller Disconnect Switch NZM9-250 With Shunt Trip

Klockner Moeller Front-Mounted Plug S201 

DIL0M-G Klockner Moeller Motor Contactor 

KLOCKNER MOELLER CI-G-135/T3-4-8440/Z NSPP CIG135T348440Z

KLOCKNER MOELLER EMT6 NSFP EMT6

KLOCKNER MOELLER FAZ-D3/2-RT USPP FAZD32RT

KLOCKNER MOELLER T3-3-8228/E NSFP T338228E

KLOCKNER MOELLER DILR22-G240VDC NSPP DILR22G240VDC

KLOCKNER MOELLER DILR40-G-24VDC NSPP DILR40G24VDC

KLOCKNER MOELLER T5B-4-15164 USPP T5B415164

3004 New-No Box, Klockner Moeller ZM-6-PKZ2 Motor Trip Module


3008 New In Box, Klockner Moeller ZM-6-PKZ2 Motor Trip Module


KLOCKNER MOELLER DIGITAL EXPANSION MODULE PLC 16OUT LE4-116-XD1 24VDC 6mA

KLOCKNER-MOELLER EBE-211 TIMER MODULE 8 CHANNEL 

Klockner-Moeller DILOAM/22 Universal Contactor - New

KLOCKNER MOELLER PKZM3-10 NSPP PKZM310

KLOCKNER MOELLER CS3 NSFP CS3

KLOCKNER MOELLER DILR22-115VAC USPP DILR22115VAC

KLOCKNER MOELLER BOB-200 USPP BOB200

KLOCKNER MOELLER DILM65-190V/50HZ-220V/60HZ USPP DILM65190V50HZ22

KLOCKNER MOELLER CDN-17 USPP CDN17

KLOCKNER MOELLER SIM1-PS3 NSPP SIM1PS3

Klockner Moeller Front-Mounted Plug S201 

KLOCKNER MOELLER PKZM0-2.5/SE00-11-110/120V NSPP PKZM025SE0011110

KLOCKNER MOELLER DILR-22-G24VDC NSPP DILR22G24VDC

Klockner Moeller Contactor DIL1M-G


KLOCKNER MOELLER EASY719-DCRCX NSFP EASY719DCRCX

KLOCKNER MOELLER SM2-P32 USPP SM2P32

KLOCKNER MOELLER S-252 USPP S252

KLOCKNER MOELLER S253 USPP S253

KLOCKNER MOELLER T3-1-102/Z+UV+FS907 USPP T31102ZUVFS907

KLOCKNER MOELLER DIL-00-52/Z0-37-240V/60HZ NSPP DIL0052Z037240V6

KLOCKNER MOELLER P3-63/Z USPP P363Z

KLOCKNER MOELLER DIL-2-AM-230V-50/60HZ USPP DIL2AM230V5060HZ

KLOCKNER MOELLER T0-4-15682/I1/SVB-SW NSPP T0415682I1SVBSW

KLOCKNER MOELLER K95/4 USPP K954

KLOCKNER MOELLER FAZ-D10/2-RT USPP FAZD102RT

Klockner-Moeller Enclosed START STOP PKZM-3-25-U-NA

KLOCKNER MOELLER NZM7-100 Circuit Breakers NZM7100 DAVO-NZM7

KLOCKNER MOELLER TO-2-6490-65/I/SVB *NEW IN A BOX*


KLOCKNER MOELLER P1-32/I2/SVB-NA *NEW*


KLOCKNER-MOELLER NZM8-200 CIRCUIT BREAKER + ZM8

 AS-IS see the description

KLOCKNER-MOELLER N6-63-CNA

Klockner-Moeller EBE211 ADJUSTABLE TIMER MODULE for industry use

Klockner Moeller DIL0M Contactor 15hp 120v 35a NEW DIL M 22


Klockner Moeller DIL00M4-G Contactor 20a Coil 24VDC DILOOM4-G starter relay NEW


KLOCKNER MOELLER P3-63/I4/SVB-NA *NEW*

KLOCKNER MOELLER PKZ2/ZM-32 *NEW*

KLOCKNER MOELLER Z5-100/FF250 Therm. Overload Relay NEW

KLOCKNER-MOELLER DIL0AMG CONTACTOR 24V DC DIL OA M-G 


KLOCKNER MOELLER CONTACTOR CAT#DIL4-22-NA 115V COIL

KLOCKNER-MOELLER PKZM3-1-NA 550/600V 40HP 0.5-0.9A MANUAL MOTOR STARTER

KLOCKNER-MOELLER PROGRAMMABLE RELAY MODULE MODEL 412-AC-R

KLOCKNER MOELLER MOTOR TRIP CURRENT LIMITER


KLOCKNER-MOELLER CONTACTOR CAT#DILR22D 120VCOIL 600V 15A

KLOCKNER MOELLER NZM 4-80 FREE SHIPPING

NEW Moeller PKZ Motor Protective Circuit Breaker Manual 50A Klockner PKZM4-50

NEW MOELLER KLOCKNER ELECTRIC DIL-0AM CONTACTOR 115V 60HZ

KLOCKNER MOELLER PKZ2 USPP PKZ2

KLOCKNER MOELLER ETR5-1 NSFP ETR51

KLOCKNER MOELLER ETS-A4-2 NSFP ETSA42

KLOCKNER MOELLER LE4-116-DX1 USPP LE4116DX1

KLOCKNER MOELLER A600-NZM10 NSPP A600NZM10

Klockner Moeller DIL4-22-NA Contactor 300 amp 600vac DIL422NA Free Shipping


Klockner Moeller 11S DIL M 11SDILM Contactor

KLOCKNER MOELLER U-NZM7-24VAC USPP UNZM724VAC

KLOCKNER MOELLER PKZM0-1.6/NHI11 NSFP PKZM016NHI11

KLOCKNER MOELLER DIL0M-110V/50HZ-120V/60HZ USPP DIL0M110V50HZ120

KLOCKNER MOELLER SM2-R8 USPP SM2R8

KLOCKNER MOELLER T1-9-15147/EZ-NA NSPP T1915147EZNA

KLOCKNER MOELLER MOTOR PROTECTION TRIP BLOCK ZM-40-PKZ2 *NEW OUT OF BOX* 


KLOCKNER MOELLER PKZM3-1-NA *NEW IN A BOX*


Klockner Moeller Front-Mounted Plug S252 

KLOCKNER MOELLER DILM-50-230V/50/60HZ USPP DILM50230V5060HZ

KLOCKNER MOELLER PKZM0-1.6-NA NSFP PKZM016NA

KLOCKNER MOELLER PKZM3-10 USPP PKZM310

KLOCKNER MOELLER EASY412-AC-RC USPP EASY412ACRC

KLOCKNER MOELLER PKZM3-0.6-U-NA USPP PKZM306UNA

KLOCKNER MOELLER PKZM3-16-U-NA USPP PKZM316UNA

KLOCKNER MOELLER T3-1-102/Z-UV USPP T31102ZUV

KLOCKNER MOELLER NHINZM10 NSFP NHINZM10

Klockner Moeller Thermal Trip Circuit Breaker 100A NZM
Model NZM6B100 Switch Disconnect Motor Protector 100A


KLOCKNER MOELLER DIL-0AM-G-24VDC NSFP DIL0AMG24VDC

Klockner Moeller DIL0AM Contactor + 31DILM Auxilary


KLOCKNER-MOELLER N6-160-CNA 150 AMP DISCONNECT SWITCH

New Klockner Moeller Relay Output Unit ETS 1-10 ETS1-10

LOT OF 7 KLOCKNER MOELLER 04DILE *NEW*

# KLOCKNER MOELLER 50 AMP NZM6B-63/ZM6A-50 600 V BREAKER W / HANDLE

KLOCKNER MOELLER PKZM0-25 NSPP PKZM02

KLOCKNER MOELLER CONTACTOR DIL1AM 110/120V NIB DIL 1AM

KLOCKNER MOELLER PKZM3-25-U-NA CONTACTOR ***XLNT***

KLOCKNER MOELLER DILR22-G240VDC USPP DILR22G240VDC

KLOCKNER MOELLER DILR40-G-24VDC USPP DILR40G24VDC

KLOCKNER MOELLER DIL-00-52/Z0-37-240V/60HZ USPP DIL0052Z037240V6

KLOCKNER MOELLER DILR40-G/22 *NEW* 


KLOCKNER MOELLER EBE250A-1 NSPP EBE250A1

KLOCKNER MOELLER PKZM0 USPP PKZM0

KLOCKNER MOELLER Z1-63 USPP Z163

KLOCKNER MOELLER DIL-1-AM USPP DIL1AM

KLOCKNER MOELLER EBE-206.1-2 USPP EBE20612

KLOCKNER MOELLER EBE-206.2-2 USPP EBE20622

KLOCKNER MOELLER PS416-INP-400 NSFP PS416INP400

KLOCKNER MOELLER A600-NZM10 USPP A600NZM10

KLOCKNER MOELLER PKZ02-1.6/CIS-NA NSPP PKZ0216CISNA

KLOCKNER MOELLER PKZ02-2.4-NA NSPP PKZ0224NA

KLOCKNER MOELLER PKZM0-16-T NSPP PKZM016T

N6-160-CNA  KLOCKNER-MOLLER DISCONNECT SWITCH 125 AMP


KLOCKNER MOELLER DILR-22-G24VDC USPP DILR22G24VDC

KLOCKNER MOELLER N64-125-VDE NSFP N64125VDE

KLOCKNER MOELLER P1-32/I2/SVB NSPP P132I2SVB

Lot of 3 - New Klockner Moeller Z00-4 Overload Relay w/ EZ00 Mounting Base


KLOCKNER-MOELLER N6-160-CNA 125 AMP DISCONNECT SWITCH

KLOCKNER MOELLER P2-30/F-CNA DOOR SWITCH CONTACTOR CNC

KLOCKNER MOELLER DISCONNECT SWITCH N6-63-CNA N663CNA BREAKER ZIMMERMAN FZ10-2

KLOCKNER MOELLER PKZ02-1.6-NA NSFP PKZ0216NA

KLOCKNER MOELLER PKZ02-6.0-NA NSFP PKZ0260NA

KLOCKNER MOELLER PKZM0-2.5/CI-PKZ0-G/NHI11-PKZ0/L-PKZ0-RT-400V NSFP PKZM025CIPKZ

KLOCKNER MOELLER DIL0M-230V-50/60HZ NSFP DIL0M230V5060HZ

KLOCKNER MOELLER PKZ2/ZM-01.6 USPP PKZ2ZM016

KLOCKNER MOELLER PKZM3-32-U-NA USPP PKZM332UNA

KLOCKNER-MOELLER PKZM3-10-NA 575V 7.5HP 5.5-9.5A MANUAL MOTOR STARTER

KLOCKNER MOELLER PKZM-3-10-U-NA NSPP PKZM310UNA

KLOCKNER MOELLER DIL00AM-G-10-DC24 USPP DIL00AMG10DC24

KLOCKNER MOELLER STK0.75-220-115 USPP STK075220115

KLOCKNER MOELLER 61-00114-001 USPP 6100114001

KLOCKNER MOELLER STZ-0.8-220-115 USPP STZ08220115

KLOCKNER MOELLER NZM6-100/ZM6A-40-NA USPP NZM6100ZM6A40NA

Moeller Klockner PKZ2 PKZ 2 ZM-10 motor starter *NEW*


Moeller Klockner PKZ2 PKZ 2 ZM-4 motor starter *NEW*


KLOCKNER MOELLER N6-63-CNA SWITCH DISCONNECTOR 63A 600V

KLOCKNER MOELLER DIL0M 240V *NEW IN A BOX*


KLOCKNER MOELLER STORE MODULE EE1-PS306 EE1PS306 

KLOCKNER MOELLER DIL 3-22-NA 120A 110V COIL CONTACTOR

Klockner Moeller Input PS416-INP-400 (3200)B


Klockner Moeller PKZ2 Motor Protector w/ZM-16-PKZ2. 

T0-3-15680/V/SVB Klockner Moeller New In Box Cam Switch T0315680VSVB


Klockner Moeller: DIL1A M AC Contactor / Starter 

KLOCKNER MOELLER EMT-5 USPP EMT5

KLOCKNER MOELLER P3-63 DISCONNECT SWITCH UNIT 63A ***NNB***

Klockner Moeller PS4 I/O Module LE4-116-DX1 LE4116DX1