PK544BW

PK544-NA

主要产品：日本东方马达，韩国DKM减速电机，泰映TROY减速电机，韩国SPG小功率
马达，CPG晟邦减速电机 ...
减速机技术资料：

星减速机以其体积小，传动效率高，减速范围宽，精度高，而被广泛应用于伺服、步进、直流等传动系统中。在保证精密传动的前提下，主要被用来降低转速增大扭矩和降低负载/电机的转动惯量比。 

       衡量行减速机性能的几个关键技术参数是：减速比，平均寿命，额定输出扭矩，回程间隙，满载效率，噪音，横向/径向受力和工作温度。 减 速 比： 
输出转速与输入转速的比值。 

       级数：太阳轮及其周围的行星轮构成独立的减速轮系，如减速机内只此一个轮系，我们称为“一级”。为得到较大减速比，需多级传动， NEUGART公司减速机分三级，减速比从3到512。 平均寿命： 指减速机在额定负载下，最高输入转速时的连续工作时间。

       额定输出扭矩： 指在额定负载下长期工作时允许输出扭矩。最大输出扭矩是该值的两倍。 回程间隙： 将输出端固定，输入端顺时针和逆时针方向旋转，使输出端产生额定扭矩的±2%扭矩时，减速机输入端有一个微小的角位移，此角位移即为回程间隙。单位是“弧分”。       

       润滑方式：行星减速机在整个使用期间无需润滑。 满载效率： 指在最大负载情况下，减速机的传输效率。它是衡量减速机的一关键指标, 满载效率高的减速机发热少，整体性能好。 

       噪音：单位是分贝（dB）A。此数值是在输入转速为3000转/分钟时，不带负载，距离减速机一米距离时测量的。 
工作温度：是指减速机在连续工作和周期工作状态下，所能允许的温度。目前，军用系列的减速机能在-50~+100度环境下工作。 如何选择合适的行星减速机 
在选择行星减速机时，首先要明确减速比。 确定减速比后，请将您选用的伺服电机额定扭矩乘上减速比，得到的数值原则上要小于产品样本提供的相近减速机的额定输出扭矩，同时还要考虑其驱动电机的过载能力及实际中所需最大工作扭矩。所需最大工作扭矩要小于额定输出扭矩的2倍。 满足上面条件后请选择体积最小的减速机，体积小的减速机成本相对低一些。如果您的空间不够电机减速机直线连接，您还可以选择拐角型减速机，它可以使扭矩转90度。 

       接下来要考虑行星减速机的回程间隙。回程间隙越小其精度越高，成本也越高。用户要选择满足其精度要求系列的减速机就可以。回程间隙指标是以同型号批量生产中回程间隙最大的一台做标准，而实际中98%以上的行星减速机实际回程间隙小于给定指标的50%。 

       还要考虑横向/径向受力和平均寿命。横向/径向受力大的减速机在安装和使用中可靠性高，不易出问题。而实际寿命可按厂家给出的软件来计算。通常其平均寿命远超过所配伺服电机的寿命。

轮减速机的安装要点
    1、减速机的输出轴上在安装传动件时，必须注意操作的柔和，禁止使用锤子等工具粗暴安装，是利用装配夹具和端轴的内螺纹进行安装，以螺栓拧入的力度将传动件压入减速机，这样可以保护减速机内部零件不会受到损坏。     2、减速机在安装时，要特别注意传动中心轴线的对中，对中的误差不能超过减速机所用联轴器的使用补偿量。齿轮减速机按照要求对中之后，可以获得更理想的传动效果和更长久的使用寿命。     3、减速机的固定非常重要，要保证平稳和牢固，一般来说我们应将减速机安装在一个水平基础或底座上，同时排油槽的油应能排除，且冷却空气循环流畅。减速机的固定不好、基础不可靠是，就会出现造成、振动等现象，也会使得轴承和齿轮受到不必要的损害。     4、减速机所采用的联轴器有多种可选类型，但不要使用钢性固定式联轴器，这类联轴器的安装比较困难，一旦安装不当就会加大载荷量，容易造成轴承的损坏，甚至会造成输出轴的断裂。     5、减速机的安装位置要保证工作人员的操作，包括可以方便的接近游标、通气塞和排油塞等位置。减速机的安装完成后，检查人员应按照顺序全面检查安装位置的准确性，确定各个紧固件的可靠性等。     6、减速机在运行前，还要做好运行准备，将油池的通气孔螺塞取下换成通气塞，打开油位塞螺钉检查油线高度，添加润滑油超过油位塞螺至孔溢出，而后拧上油位塞并确定无误后，可以开始试运行。     7、减速机的传动联接件在必要时应加装防护装置，例如联接件上有突出物或使用齿轮、链轮传动等，如果输出轴承受的径向荷载较大，也应当选用加强型。

Reliance Electric Flex Pak Plus Drive 14C520

NEW RELIANCE ELECTRIC 0-51845-1 PRINTED CIRCUIT 

RELIANCE ELECTRIC RECTIFIER STACK 86474-IS

Reliance Electric GP-2000 AC V-S Drive 3HP New

Reliance Electric 51865-9 Circuit Board

RELIANCE ELECTRIC P2865276D 25-HP 841XL 3-PH 3550-RPM 0284TS-FR ELECTRIC MOTOR

RELIANCE ELECTRIC COUPLING 400821-18A

Reliance Electric Printed Circuit Loop Card 0-51865-9 

Reliance Electric Thyristor 86466-12R

RELIANCE ELECTRIC 809'53-00 CIRCUIT CARD


Reliance Electric Drive GP-1200 1AC4103U-RP-012 4.2 KVA 3 HP 460 V

Enlarge
RELIANCE ELECTRIC 0-49020-4 0490204 CONTROLLER CARD NEW

NEW RELIANCE ELECTRIC DC2-42UF VS DRIVE 

Reliance Electric Motor P14G9258_2HP_IP44_60 Hz_1750 RPM_Class F_Des B


RELIANCE ELECTRIC MOTOR HAZARDOUS EXPLOSION PROOF P18G1183A 182TC 3 HP 3 PH NEW

RELIANCE ELECTRIC O-48664-2 O486642 0-48664-2 VLTG TRANSDUCTOR NEW

NIB RELIANCE ELECTRIC 69326-31R CONTROL RELAY MODULE 6932631R


NEW RELIANCE ELECTRIC 602909-68AE TRANSISTOR 60290968AE

NEW RELIANCE ELECTRIC 0-52012-3 DRIVER BOARD

RELIANCE ELECTRIC AC DRIVE VARIABLE SPEED GP-2000 "NEW"

RELIANCE ELECTRIC PRINTED CIRCUIT AUX M KIT 0543791

Reliance Electric 0-57412-D DCS Field Regulator

NEW RELIANCE ELECTRIC B-57300 CIRCUIT BOARD MODULE PLC CARD 54758

NEW RELIANCE ELECTRIC 57C409 2-CHANNEL ANALOG INPUT MODULE PLC 15V DC REV 55043

RELIANCE ELECTRIC AC VS DRIVE GP-2000 CONTROL PANEL

RELIANCE ELECTRIC 1SU51007 SP500 7 1/2 HP. GOOD DRIVE

Reliance Electric Semikron 701819102AW Diode | NEW NIB


RELIANCE ELECTRIC ETR 38 90 POWER SOURCE BOILER PRECEPITATION BOARD TB800 58223

RELIANCE ELECTRIC ETR 51 52 TB600 POWER SOURCE BOILER PRECIPITATION BOARD 58224

NEW RELIANCE ELECTRIC LIMIT MODULE CARDPAK 0-49008-3


Baldor Reliance industrial pump motor 3hp M8A 103049270-001 M36K77-2759

RELIANCE ELECTRIC 57C-409 INPUT MODULE (1933)

Reliance Electric 756H109AA-ST Power Matched DC Motor


Reliance Electric Printed Circuit Gate Coupling Card w/ 700874-66A 0-51378-6 NIB

RELIANCE ELECTRIC 0-51851 CRCA CONTROLLER NEW SURPLUS


Reliance Electric LSCA Board 0-51884 #34551

Reliance Electric 0-49040 Cardpak Controlled Rectifier 

1 NEW RELIANCE ELECTRIC DUTY MASTER A-C MOTOR 

Reliance Electric IMPakPlus VS Drive 

RELIANCE ELECTRIC DISTRIBUTED CONTROL SYSTEM RESOLVER INPUT 57411-2C

NEW RELIANCE ELECTRIC VSDRIVE SP500 EASY CLEAN PLUS


Reliance Electric 0-51863 

ALLWEILER AS0102 EW2 PUMP WITH RELIANCE 1HP AC MOTOR

RELIANCE ELECTRIC DRIVE DIGITAL I/O MODULE 57401-2

Reliance Electric HR2000 / BLA-08 Brushless AC Servo 

RELIANCE ELECTRIC 0-55325-9 PRINTED CIRCUIT VOLTAGE TO ISOLATOR MODULE 56915

RELIANCE ELECTRIC GV3000 AC DRIVE 1V2150

RELIANCE ELECTRIC 57402-D 115VAC/DC OUTPUT MODULE 16 CHANNEL M/N 57C402 QUANTITY

Reliance Electric AC VS Drive GS-2000 200/230 VAC 3 Phase 2Hp 2GU21002 + In/Out

RELIANCE ELECTRIC 1.7KVA 1HP VARIABLE SPEED AC DRIVE 1AC2001 *LOT OF 3*

RELIANCE ELECTRIC HR2000/BLA-08 SERVO DRIVE GOOD TAKEOUT


RELIANCE ELECTRIC 14C109A FLEXPAK PLUS 5 HP GOOD TAKEOUT

RELIANCE ELECTRIC HR2000/BLA-16 SERVO DRIVE GOOD TAKEOUT


RELIANCE ELECTRIC SP 500 VS DRIVE 1SU41002 (2 HP)

RELIANCE ELECTRIC HR2000/BLA-12 SERVO DRIVE GOOD TAKEOUT


Reliance Electric Flexpak Plus VS Drive 40HP.....

RELIANCE ELECTRIC 57456-B 115VAC INPUT MODULE 16-CHANNEL M/N 61C500

RELIANCE ELECTRIC 45C-968 USPP 45C968

VERY NICE RELIANCE ELECTRIC HVAC FREQUENCY DRIVE VTAC7

RELIANCE ELECTRIC AUTOMATE 45C1 I/O RAIL W/ 8 MODULES 1

New Reliance Electric Single Phase Motor C56H3681M 1/3HP 1140RPM FRAME:FJ56C


New Reliance Electric Digital Meter 9C112 3.5 Digit DPM 35 BP


Reliance Electric IRCG Board 0-51839-6 #34574

Used Reliance Electric VS Drive SP500 1SU44003 3HP Drive 380-460VAC 3PH 6.4A

RELIANCE ELECTRIC 0-57408-1C Interface Mod 574081C New

Reliance Electric CVTB Board 0-51831-1 #34555

Reliance Electric MasterXL Speed Reducer 56CM12A 192 Ratio, 1750RPM

Reliance Electric Master XL Speed Reducer 56WM16A Ratio 30, 1750RPM

SC-165, RELIANCE ELECTRIC 20 HP MOTOR

Reliance Electric Comp. AC Motor P56A1337W-UZ 3/4HP 1725RPM

RELIANCE ELECTRIC 57457-B 24VAC/DC INPUT MODULE M/N 61C515 QUANTITY!!

RELIANCE ELECTRIC 77801-18KXX NSFP 7780118KXX

RELIANCE ELECTRIC 0-49001-5 USPP 0490015

1 HP 1800 RPM Reliance ULTRA KLEEN Stainless Steel Electric Motor

Reliance Electric 57405-E 0- 57405E Analog I/O Drive Module - Used


Reliance Electric 0-51865-2 PC Board CLDC 0518652

RELIANCE ELECTRIC 0-57516-1 USPP 0575161

RELIANCE ELECTRIC 57C-331 USPP 57C331

Reliance Electric 104042 Flange Block Non-Exp Dodge Type C 

RELIANCE ELECTRIC A77B5902P NSPP A77B5902P

RELIANCE ELECTRIC 401286-15P USPP 40128615P

RELIANCE ELECTRIC A77B5901N-AA NSPP A77B5901NAA

RELIANCE ELECTRIC 9C111 USPP 9C111

RELIANCE ELECTRIC 9C-112 USPP 9C112

RELIANCE ELECTRIC 0-52524 NSPP 052524

RELIANCE ELECTRIC 45C901 USPP 45C901

1 NIB RELIANCE ELECTRIC T56S1019B 1/4 HP DC MOTOR 1750 RPM


1 NIB RELIANCE ELECTRIC 0-57400-1 0574001 INPUT MODULE


RELIANCE ELECTRIC 608870-31R USPP 60887031R

RELIANCE ELECTRIC 64670-6RX NSPP 646706RX

NIB RELIANCE ELECTRIC 613613-40S 61361340S FIBER OPTIC
CABLE


Reliance Electric 8K Memory # 45C270


1 NIB RELIANCE ELECTRIC 613613-27S OPTIC CABL 61361327S


1 NIB RELIANCE ELECTRIC 613613-600R CABLE 613613600R


1 NIB RELIANCE ELECTRIC 613613-31S CABLE 61361331S


1 NIB RELIANCE ELECTRIC 613613-30S CABLE 61361330S


1 NIB RELIANCE ELECTRIC 613613-36S CABLE 61361336S


1 NIB RELIANCE ELECTRIC 613613-38S CABLE 61361338S


1 NIB RELIANCE ELECTRIC 613613-650R CABLE 613613650R


1 NIB RELIANCE ELECTRIC 613613-29S CABLE 61361329S


1 NIB RELIANCE ELECTRIC 613613-28S CABLE 61361328S


Reliance Electric Automate 45C270 8K MEMORY EXPANSION

RELIANCE ELECTRIC 64670-21R CURRENT TRANSDUCER 6467021R NEW


1 NEW RELIANCE ELECTRIC 057403F OUTPUT MODULE 16 POINT


1 NEW RELIANCE ELECTRIC 057403 OUTPUT MODULE 16 POINT


RELIANCE ELECTRIC 0-48680-300 INTERFACE MODULE 04680300


RELIANCE ELECTRIC 48267-L RESISTOR 48267L 9.420OHM NIB 


1 NEW RELIANCE ELECTRIC 0-57401-C 057401C DRIVE DIGITAL


NIB RELIANCE ELECTRIC 613613-700R 613613700R FIBER 
OPTIC CABLE


RELIANCE ELECTRIC BDC-25L SERVO CONTROL 9106-0059

NIB RELIANCE ELECTRIC 613613-41S 61361341S FIBER OPTIC
CABLE


NIB RELIANCE ELECTRIC 613613-34S 61361334S FIBER OPTIC
CABLE


RELIANCE ELECTRIC 1GA687174 (103774-64) AC DRIVE

RELIANCE ELECTRIC SP500 1SF44002 ONYX DRIVE 2HP TESTED

RELIANCE ELECTRIC 0-52835 SCSA PRINTED CIRCUIT CONTROL BOARD CARD PCB 51919

RELIANCE ELECTRIC 0-58706-2 NSPP 0587062

RELIANCE ELECTRIC 3EB1 USPP 3EB1

RELIANCE ELECTRIC AC MOTOR 20HP 460V 3PH 3530RPM L2158C 01KS502312F 18214 

RELIANCE ELECTRIC 121191-170 USPP 121191170

RELIANCE ELECTRIC 612-234-RJ NSPP 612234RJ

RELIANCE ELECTRIC 6MDAN-8P0101 NSFP 6MDAN8P0101

RELIANCE ELECTRIC 402422-3P NSPP 4024223P

RELIANCE ELECTRIC 48267-B USPP 48267B

RELIANCE ELECTRIC 64960-27R NSFP 6496027R

RELIANCE ELECTRIC A77B5901M-PR NSPP A77B5901MPR

RELIANCE ELECTRIC 0-52830 NSPP 052830

RELIANCE ELECTRIC 610266-27T NSFP 61026627T

RELIANCE ELECTRIC 9097-1094 USPP 90971094

RELIANCE ELECTRIC 0-51434-6 USPP 0514346

RELIANCE ELECTRIC 0-51447-2A USPP 0514472A

RELIANCE ELECTRIC 0-54392 USPP 054392

RELIANCE ELECTRIC 0-54392-2 USPP 0543922

Reliance Electric 0-55325-8 0553258 Circuit Board - New, No Box


RELIANCE ELECTRIC 86377-1R USPP 863771R

RELIANCE ELECTRIC 413366-1AF NSFP 4133661AF

RELIANCE ELECTRIC P18G431H USPP P18G431H

RELIANCE ELECTRIC 64690-5RA NSFP 646905RA

RELIANCE ELECTRIC 0-52014 NSFP 052014

RELIANCE ELECTRIC P14X3256T-RZ USPP P14X3256TRZ

RELIANCE ELECTRIC P14X3256T-TZ USPP P14X3256TTZ

RELIANCE ELECTRIC A77W8190M-NS USPP A77W8190MNS

RELIANCE ELECTRIC 0-57003 NSFP 057003

RELIANCE ELECTRIC MR94762 NSFP MR94762

RELIANCE ELECTRIC MR94763L1 NSFP MR94763L1

1 NIB RELIANCE ELECTRIC 45C994 OUTPUT MODULE 2 POINT ANALOG 0 - 10 V


1 NIB RELIANCE ELECTRIC 0-52823 052823 DIGITAL FIRING CIRCUIT SEALED 


1 NIB RELIANCE ELECTRIC 0-51845 051845 POWER SUPPLY BOARD


RELIANCE ELECTRIC 14C-429 USPP 14C429

NIB RELIANCE ELECTRIC S2C332A 10 SLOT RACK PANEL MOUNT


Reliance Electric Drive Analog Module 57405-D

Reliance Electric 1SU41002 SP500 VFD 2HP Speed Drive

Reliance Electric 0-56301 Base Driver 056301 New

RELIANCE ELECTRIC DC1-27 USPP DC127

RELIANCE ELECTRIC 0-52861-1 USPP 0528611

1 NIB RELIANCE ELECTRIC 0-54379-10 05437910 CARD


RELIANCE ELECTRIC 612230-R NSFP 612230R

RELIANCE ELECTRIC 0-54381 USPP 054381

RELIANCE ELECTRIC 0-51445 CONTROL BOARD ***XLNT***

RELIANCE ELECTRIC T56H1042N-SP USPP T56H1042NSP

RELIANCE ELECTRIC 0-51829-1 USPP 0518291

RELIANCE ELECTRIC 1SU20002 USPP 1SU20002

RELIANCE ELECTRIC 45C-914 NSFP 45C914

Reliance Electric 57C409/57C-409 Ser E Analog Input


Reliance Electric 57C409/57C-409 Ser D Analog Input

Reliance Electric 57C409/57C-409 Ser H Analog Input


RELIANCE ELECTRIC S20-402P0-B1000 NSFP S20402P0B1000

RELIANCE ELECTRIC T-100B USPP T100B

RELIANCE ELECTRIC 411027-20S NSFP 41102720S

Reliance Electric Drive Digital I/O Module 57401-2


Reliance Electric 3 HP VS AC Drive GP1200 1AC4103U 460V RE 1AC4103-U 3HP

RELIANCE ELECTRIC MOTOR (MOTOR ONLY) W/O ENCODER DEK 660-1A(SCR)+RM21-500-LD*M*

NEW RELIANCE ELECTRIC 0-55325-8 PC CURRENT VOLTAGE CARD 54655

Reliance Electric 01482-1079-000-10 P/N 1140-001-1729 T 

Reliance Electric M1140 P/N 1140-001-1729 

RELIANCE ELECTRIC 0-51865 CURRENT RATE/GAIN LOOP DRIVER CLDA PCB MODULE

RELIANCE ELECTRIC 8C59D IMPAK VS DC DRIVE 3HP 230V 19A

***NIB*** Reliance Electric Shark Prog. Cont. # 45C904

RELIANCE ELECTRIC P14H1447 AC MOTOR 1.5 HP NEW