IC660BBD022

IC660BBD022

IC660BBD022

IC660BBD022

  起动接触器得电与否，应取决于柴油机管路内的油压状况。理想的控制应是以滑油压力和燃油压力作为控制信号，这样在首次起动时，如果油压建立不起来或油管路中存在问题时，将不会起动柴油机。而目前在起动过程中主要是在45s~60s 延时后，由人为观测滑油压力表和机油压表，假定在45s~60s 的延时过程中，油压一定会建立起来这样一种假设的情况下，进行Q C 得电控制的，缺乏控制手段。为此，可采用压力传感器来提取机油和燃油压力信号，并将其通过转换输入到PCC 中，由PCC 根据设定值判断和执行QC 的得电控制。 

       2.2 根据点火时柴油机的转速进行停止起动电机（QD）运转的控制 
       柴油机起动是否成功，关键在于柴油机是否能正常点火，作为起动的终止应受控于柴油机发火转速，如果因为某种原因不能正常起动，则应自动停止起动，以减少蓄电池的放电量和避免起动接触器烧死。正常情况下，东风4型系列机车柴油机起动时，点火转速在150r/min 左右，稳定运转的最低转速为430r/min。如果采取转速传感器测出柴油机的转速，并将转速信号输入到PCC 中，由PCC 判断和控制QC 的开断，即控制蓄电池向起动电机供电：（1）可节省蓄电池的电能，有利于蓄电池的保养；（2）电动机由驱动转动变为柴油机的负载，可降低柴油机起动的转速冲击。 

       2.3 对电磁联锁DLS拖后供电控制，实现向气缸适时喷油 
       在柴油机起动过程中的低转速阶段向气缸内供油，由于油温较低不能达到完全燃烧，同时，又会降低气缸燃烧时的温度，造成起动困难，甚至爆燃。因此，可采用对起动接触器及调速器内D LS 电磁联锁线圈进行单独供电控制。这样，可使柴油机先转动，后拉动喷油泵供油齿条，以此来拖后向气缸内供油。 

       鉴于当柴油机由起动电机拖动运转，转速接近或达到点火转速时向气缸内喷油最有利于柴油机点火，因此，DLS 线圈得电与否应取决于柴油机拖动转速。不同的柴油机或同一柴油机在不同的工作环境和状态下，其点火转速是不同的。与点转速有关的因素主要有气缸内的温度、压力、氧气含量和燃油的雾化状态，影响气缸内温度的主要因素为油水温度，所以对DLS 电磁联锁线圈的控制可采用温度传感器检测油水温度来进行控制。 

AP200 Shuttle adaptor kit, AP20-K-250

APPLIED MATERIALS PCB, SIGNAL CONDITION, ASSEMBLY

APPLIED MATERIALS ARC CHAMBER P19500

LAM RING, CLAMP-UPPER ELECTRODE

Trebor Model 85 Surge Suppressor

Finish Thompson / FTI Vertical Mag Drive VKC80VST336

Finish Thompson / FTI Vertical Mag Drive VKC80VST348

APPLIED MATERIALS INC. VANE, (MRS)P19500 AMI

Speedfam Load Cup

Lambda Power Supply, 500W, 24 VDC, FE050024RA

Applied Materials Gas Distribution Plate

DNS ELECTRONICS ARM, IH (2)- 80A SCRUBBER

OMRON CAPACITIVE PROXIMITY SWITCH, E2K-C25MF1

Applied Materials 0020-82550 HOLDER (MRS) P19500

SMC VALVE SHUTTLE CAM PUMP F25 KT-PA2-38

Semitool OPTICAL BOARD ASSEMBLY 16730-01

APPLIED MATERIALS INC. HOLDER (MRS) P19500 

Akrion Steag Valve PVDF610/15/D 7205A1 410200

APPLIED MATERIALS COVERING PIPE, 0020-0930

DNA CERAMIC IH ARM L=110MM 2-F3-31399

DAIFUKU MOTOR, CONV. ORIEN. TRAVEL BODY

Watlow Din-A-Mite DB2C-2060-C050

Yaskawa Digital AC Servo Drive

Lambda Power Supply SC150U03

Lee ATMI Micropump LPVX0505600CA

Applied Materials 0020-81482

Applied Materials 0020-82822

TRIPP LITE UPS System SMARTINT700

ATMOS Air Handling Filter 2FM-22

Clean Room Products Air Handling Filter U3030A00ADACACA

Parker Motor MPC 1140X

Harowe Resolver 31BRCX-500-B1

Pacific Scientific Motor R63FSSA-HS-SS-N?V-04

POLYPURE BATH

SENSOR, SOG FLOW 3x2 N.C. ST215A

DYTEC VALVE, DUMP RINSER, QDV-400-PVDF-V

SMART UPS 1000VA BATTERY BACKUP

APPLIED MATERIALS HEATER BAND FOR TMS KIT, 1410-01124

DWYER PHOTOHELIC GUAGE, KC-3003MR

APPLIED MATERIALS SHOWER HEAD,5B PUTTER ETCH 0020-09933

MIKRO ELEKTRONIK M34, M-Module, 04M034-00

BALZERS ROLLE COUPLING, BB180942-T

EIT SENSOR STIK, 0-25 PPM, SERIES 4500

DELCO BATTERY BACK-UP, RST31

Circuit Board DAMPER CD BG4-8615

Circuit Board M-POS (CONVERTER) BG8-3326 BH8-1970-01

Circuit Board CDIF BG4-6631 BH8-1823 BG8-2676

DAIFUKU CO. LTD. BOARD (TFE) DAIFUKU P.C.-3419B

EARTH LEAKAGE BREAKER ASSEMBLY #5, 

Circuit Board LIBRARY CONTROL PCB BG4-8193

HRD SENSOR PCB BG4-6583

CIRCUIT BOARD VEDZ-177 COMBX

JENCONS VAC SEAL

VARIAN TYPE 572 IONIZATION GAUGE, K7360301

Applied Materials 0020-04076 

LAM ENCODER ASSEMBLY, MOTOR STEPPER ARM DRIVE

EDWARDS SERIES 1 EXHAUST MODULE

VARIAN ANGLE VALVE, L6281-301

VARIAN ANGLE VALVE, L6281303

Tripp-Lite Power Supply System OMINSMART 700

Applied Materials 0020-25662 SHIELD, CLAMP, SCRWLES- CO

Humphrey Solenoid Bank ST022601CJ-01
3 way/port

LAM PC Assembly 28-8875-012

APPLIED MATERIALS INSERT PINS, SILICON,125 MM,0200-3671

Pepperl+Fuchs Dual Discrete Signal Isolator Switch EX2

LEYBOLD POWER SUPPLY, 100/250

Ontrak Extender Arm Bracket 13-8800-047-02

Swagelok Bellows valve NC ACTUATOR SS-8BK-VCR SS-6BK-1C

Dwyer CFH Flow meter 300PSIG Max

SWAGELOK VALVE 2 WAY 1/4 VCR SS-43GVCR4-1466

Futurestar Fiberoptic Sensor Flowmeter 400-003-80

CONTEMPORARY CONTROLS STANDARD NETWORK CARD SB871660-10

VALVE, AIR OPERATED RK-AOV

MRC Eclipse Receiver Remote Control Board, 883-87-000

METRON TECHNOLOGY, THERM-X RODS 0641-0767-02 TYPE R

USHIO SUPER HIGH PRESSURE MERCURY LAMP USH-350DP

ZIEHL-ABEGG ELECTRONIC SPEED CONTROLLER, PAE10E-M

GasFlo Products, Inc. PT SERIES CGA PT-AP-724SS-4TS

GasFlo Products, Inc. PT SERIES CGA PT-AP-638SS-4TS

Idec 24 VDC Power Supply (CDUs) PS5R-D24

MICRORAM 48V MOTOR AMPLIFIER, 208718-1

DAIFUKU BOARD (MCP) DAIFUKU P.C.

Malema Flow Switch M60-6T-SS-SP

Patlite Light Tower WM-302T

SUNX Wafer Sensor M-826

LAM SERVO MOTOR, 853-013720-608

Baldor 2 HP Motor VM555

Flanders Air Handling Filter

Flanders Air Handling Filter

LAM ASSY, VACUUM SWITCH, 100 TORR 853-017480-002